Parts Manual for
HYDRO DRIVE ELECTRIC CLUTCH
LAWN TRACTOR
LT-100 SERIES
MODEL
CLT23460 (7800344)
CLT24520 (7800345)
LT23460 (7800207)
LT24520 (7800212)
SLT23460 (7800342)
SLT24520 (7800343)
McDonough, GA, 30253 U.S.A.
Briggs & Startton Yard Power Products Group
Manual No.
7006261
Copyright © 2008
Briggs & Startton Corporation
Milwaukee, WI USA. All Rights Reserved
Revision C, 1/30/2008
TP 400-5330-C-TC-N
Table Of Contents
PAGE
4
GROUP
Hood / Seat Group
Steering Group
8
Main Frame Group
10
14
18
20
22
26
30
32
34
36
38
40
42
44
46
Motion Drive Group
Fuel Tank Group
Engine Group
46" Mower Housing Assembly
46" Mower Deck Group
50" Mower Housing Assembly
50" Deck Blade Drive Assembly
50" Deck Housing Suspension Assembly
52" Mower Housing Assembly
52" Deck Blade Drive Assembly
52" Deck Housing Suspension Assembly
Decals
Electrical Group
Wiring Schematic
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
3
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
4
Hood / Seat Group
Item Part No
Qty Description
Note
1
2
3
4
5
7091016
721487
4
1
1
2
1
1
2
4
1
1
1
1
16
2
1
1
1
1
1
12
12
1
1
1
1
1
1
1
1
1
1
1
1
1
2
2
1
HWST 1/4CX5/8
BEARING, STEERING
7101355
1960392
1732031
1732030
1933896
7090952
7101493
7101770
7101771
725181
CONSOLE TRACTOR
SCREW, PHILLIPS HD
HOOD GUIDE, RH
HOOD GUIDE, LH (not shown)
NUT, HEX LOCK 10C W/ NYL INSERT BZ
SCREW, 1/4-20 THREAD CUTTING
CUTTING HEIGHT INDICATOR
POD W/ DETENT
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
33
34
35
36
POD W/ COMPARTMENT
CONTAINER, BATTERY
CAPSCREW, 5/16-18
722858
722411
SPRING, COMPRESSION 2.43LENGTH
SEAT DECK
7300677D
1727294D
1727295D
1722110D
1731891
1960295
1930641
7102076
7300820
7101894
7300805
7101891
7102074
7300696Z
7300697Z
7300810Z
7400252Z
7101860
721257
PANEL HOOD RH SIDE
PANEL HOOD LH SIDE
HOOD, W/ LOUVERS
AIR DUCT, PLASTIC
SCREW, HEX WZ LOCK FLNG 1/4-20X0.625 BLK
HFLN, 1/4-20 LARGE BLK
CRUISE ROD LINK
LATCH, CRUISE
(was 7400261, weldment)
ROD, PIVOT CRUISE
CHANNEL - CRUISE
CRUISE - ACTUATOR
PULL KNOB, 1/4-20 THREAD
DASH, SUPPORT BRKT RH
DASH, SUPPORT BRKT LH
BRACKET, SUPPORT CRUISE
WELDMENT, CLUTCH ROD SUPPORT
SEAT, HI BACK
SUPPORT, SEAT
7300875D
720102
SUPPORT, SEAT
used on model SLT24520
BOLT, SHOULDER 5/16-18
CAP, PUSH ON
720360
721259
ROD, PIVOT
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
5
Hood / Seat Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
6
Hood / Seat Group
Item Part No
Qty Description
Note
37
38
39
40
41
42
43
44
44
45
46
47
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
721214
1
4
2
2
1
1
1
1
1
2
1
1
1
12
1
1
1
1
1
1
2
2
1
1
1
1
2
2
1
1
SPRING, LEAF
722851
SCREW 1/4-14X.38”ST-
FW, .34X.62X16GA
720163
721425
BOLT, WING, 0.62L X 5/16-18 UNC 2A
BOLT, SHOULDER 1/4-20 X 3.652 2A
WASHER, CUP, 1.50 OD X 0.344 ID
SPRING, COMPRESSION 4.57 FREE LENGTH
PIVOT, BRACKET SEAT
BRACKET SEAT PIVOT
HLN, 5/16-18-3B YZ ESNA
NUT, 1/4-20 HF
720101
721258
727614
721531
7300794D
7091298
720146
used on model SLT24520
used on model SLT24520
721276
PLATE, INDEX
7300865Z
720182
PLATE, INDEX
FASTENER PANEL
7101772
7101773
7300818Z
7300772Z
7300658Z
7300657Z
7101657
720142
MAT, LEFT
MAT, RIGHT
STIFFENER, STEERING
BULKHEAD
HOOD, PIVOT LH
HOOD, PIVOT RH
BOLT, SHOULDER
NUT, HEX FLANGE, 3/8-16 NC
HARNESS, HEADLIGHT, TCT, 1/4 TERMINALS
HEADLIGHT ASSY (Includes #'s 59, 60, 61, & 62)
REFLECTOR, HEADLIGHT
LENS, HEADLIGHT
7101458
1727296
1728973
1728974
1723451
1677371
1728059D
7101810
SOCKET, LIGHT
BULB, 12.8V (1141)
GRILLE, SNAPPER
INSERT, LIGHT BAR
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
7
Steering Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
8
Steering Group
Item Part No
Qty Description
Note
1
2
729275
727628
720973
7101525
722867
721242
725138
720119
722620
721318
7101566
1
1
1
1
2
1
1
1
2
2
2
COVER, INTEGRA
STEERING WHEEL (SOFT RIM)
BELLOWS - STEERING POST
STEERING POST - 24.56” LONG
CAPSCREW 5/16-18
3
4
5
6
BEARING - LOWER
7
GEAR PINION
8
SNAP RING, 0.543”ID
9
FW, 1.862X .765 X 16GA
HUB CAP
10
11
WHEEL & TIRE ASSY, 18X6.50-8
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
9
Main Frame Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
10
Main Frame Group
Item Part No
Qty Description
Note
7400221Z
1
1
1
54
5
1
1
1
1
1
1
1
1
1
3
6
2
2
1
2
3
1
1
1
2
1
1
1
2
1
4
4
1
1
1
2
2
ASSEMBLY, MAIN FRAME
RAIL, FRAME LH
(includes 1 thru 54 below)
was M721603
1
7300869
7300870
722858
2
RAIL, FRAME RH
was M721604
3
CAPSCREW 5/16-18
4
729075
SCREW, THREAD FORMING 10-24X.340MIN THREADS
TOP, REAR PLATE
5
7300876
7300866
7300864
7300689
7300741
722616
was M728900
was M728478
was M726871
6
PLATE, REAR
7
PLATE, HITCH
8
PLATE, IDLER PULLEY HYDRO GEAR
BRACKET, BATTERY SUPPORT
WASHER PLAIN .406 X 2.25
BRACKET, PIVOT
9
was 7300741
was M721190
was M725122
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
7300819
720099
SHOULDER BOLT, 1.563L X 0.75D X 9/16 X 3/8-16
LIFT HANDLE LINK
7300877
7091809
7091619
7013866
725131
PIN, COTTER 1/8 X 1.25 YZ
HFLN, 3/8-16 YZ
WASHER 1-1/2 OD
SPACER - LIFTER PIVOT
LIFTER WELDMENT
7500525
7300868
721221
PLATE, STIFFENING
was M728409
PIN - THREADED SHOULDER
PLATE, ENGINE
7300863
7300817
7300830
7091008
7500601
7300831
7400237
7092081
7300751
725130
was M721187
was M725215
was M721271
BRACKET, MUFFLER MOUNTING
BRACKET, TRANSAXLE LH
RHSSNB, 3/8CX2-1/2
ASSY, IDLER BRKT (SECONDARY)
BRACKET, TRANSAXLE RH
WELDMENT - BRAKE LEVER
HFLN, 5/16-24 BZ
was M721270
was M721456
BRACKET, HANGER REAR
BEARING SPINDLE
7010935
729160
WASHER, .77X1.13X.06
GT AXLE - CAST IRON
7400232
7400231
720142
WELDMENT - SPINDLE LH
WELDMENT - SPINDLE RH
NUT, HEX FLANGE, 3/8-16 NC
FW, .41 X.82 X 16GA
720166
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
11
Main Frame Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
12
Main Frame Group
Item Part No
Qty Description
Note
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
720192
2
2
1
1
1
2
1
3
2
1
2
1
1
1
1
1
2
2
BOLT, HEX, 3/8-16 UNC X 1.50 BRIGHT ZINC
WASHER, FLAT, 25/64” ID X 1” OD X 14 GA.
HANGER, DECK RH
722580
7300861
7300860
7300742
720211
was M721198
was M721199
was M728334
HANGER, DECK LH
AXLE, HANGER
HHB, 5/16-24 X 2.75 BOLT
SECTOR GEAR ASSY (GEAR DRIVE - LT)
HFLN, 5/16-18 BZ
7500524
7090585
720103
BOLT, SHOULDER 3/8-16
PLATE, STEERING MT
SCREW - GUIDE
7300867Z
721293
721240
GEAR - SECTOR
721241
BEARING - SECTOR GEAR
HHCS, 5/16-18 X 1 YZ
7027168
7101805Z
7101806Z
7091619
721095
DRAG, LINK LH
DRAG, LINK RH
HFLN, 3/8-16 YZ
FITTING - LUBRICATION (1/4-28 Self-Tap)
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
13
Motion Drive Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
14
Motion Drive Group
Item Part No
Qty Description
Note
1
1
2
7101332
7101669
7101569
7101568
7101567
7012234
7101563
7101562
7101558
7012234
720215
1
1
2
1
1
1
2
1
1
1
4
1
1
1
1
4
2
2
2
1
2
1
2
3
1
1
2
8
4
1
1
1
5
1
1
1
1
TRANSAXLE, HYDRO GEAR #310-0510
TRANSAXLE, HYDRO GEAR #310-0610
ASSY, WHEEL & TIRE, 22X9.50-12 (incl. next 3 items)
TIRE, 22X9 50-12 2PLY K358
RIM, 12X7 INT W/3 5 LG HUB SILVER
VALVE STEM, TR 412
used on 21 H. P.
used on 23 H.P. & 24 H.P.
used on 23 H.P. & 24 H.P.
3
ASSY, WHEEL & TIRE, 20X10-8 (incl. next 3 items)
TIRE, 20X10-8 2PLY K358
used on 21 H. P.
RIM, 8 X 7 BROACHED HUB WHEEL SILVER
VALVE STEM, TR 412
4
HHB, 5/16-18X2.50
5
727761
BOLT, 3/8-16 x 2” Square Neck Carriage
SPRING, Extension Lift
6
722440
7
721204
STUD, Spring Mounting (5/16-18)
STUD, Swivel (3/8-16)
8
725137
9
720145
NUT, HEX FLANGE LOCK, 5/16-18 NC
FW, 1.862X .765 X 16GA
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
722620
720010
E-RING, .750D X .050T
721318
HUB CAP
720142
NUT, HEX FLANGE, 3/8-16 NC
NUT, 1/4-20 Hex Flange Lock (Nyloc)
PLATE, Forward Stop
2860694
7300888
7091495
7900057
7101653
7035500
720258
SCREW, 1/4-20 x 3/4” Hex Head Cap, GR 5
SCREW, #12-24X.50 HWST
FAN 7.0” (TEN BLADE)
BELT, DUAL SPINDLE BRAKE
3/16 SQ KEY - REAR WHEELS
HEX NUT, 5/16-18 FLANGE SER YZ
BOLT, 5/16-18 x 5/8” Hex Head, GR 5
TORQUE BRACKET - HYDRO
BRKT, ROLL RELEASE
HA Sect.; 85.4” Effective Length
720139
720018
7300684Z
7300701Z
7101542
720069
ROLL RELEASE LEVER
HAIR PIN, .56D-.092T
7101453
7102053
7046451
7300682Z
ROD - REAR DRIVE
ROD, PIVOT DRIVE
SWIVEL, Adjustment (3/8-24)
BRACKET SUPPORT
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
15
Motion Drive Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
16
Motion Drive Group
Item Part No
Qty Description
Note
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
7200130
722598
7400248Z
1721675
720049
727933
7101454
7500602
722451
721419
725178
725167
725177
720148
721420
7300934
720100
7101801
720164
720387
726795
7101489
7101455
720870
720257
2
2
1
1
3
1
1
1
1
1
1
1
1
2
1
1
1
1
2
1
1
1
1
1
1
SPACER, AXLE
WASHER, 3/4 I.D. x 1-1/4” Flat
WELDMENT, FOOT CONTROL
PAD, FORWARD FOOT
BOLT CARRIAGE, 5/16-18 X .62
SPRING, Extension
ROD - FRONT DRIVE (3/8-24)
WELDMENT, IDLER ARM
SPRING CLUTCH
PIVOT BUSHING
IDLER PULLEY - 3” DIA.
SPACER 1/2” TO 17MM
IDLER PULLEY - 2.75 DIA.
NUT FLANGE, 3/8-16 ZINC PLATED
NUT-TEE (3/8-16)
LINK, Clutch
SHOULDER BOLT, 1/4-20X3.75
SPRING, HYDRO BRAKE
WASHER, .39 Flat
PIN, .090 x 3/4” Cotter
LATCH - PARKING BRAKE
ROD - CLUTCH DRIVE (3/8-16)
ROD - PARKING BRAKE
GRIP
CLUTCH / BRAKE PEDAL
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
17
Fuel Tank Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
18
Fuel Tank Group
Item Part No
Qty Description
Note
1
2
3
4
5
6
7101521
7101520
727333
1
1
1
1
2
2
FUEL TANK, TRACTOR W/CAP (SNAPPER)
FUEL TANK, TRACTOR
FUEL CAP
(or 7101421 Cap w/tether)
7300653Z
722866
TANK BRKT
SCREW .25-20 X0.59 HEX
HWST 1/4CX5/8
7091016
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
19
Engine Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
20
Engine Group
Item Part No
Qty Description
Note
1
1
* ENGINE, 19.5HP B&S INTEK SINGLE CYL Mod. 445577-0755- (not shown)
E1
1
1
1
1
2
1
1
1
1
1
4
2
1
1
1
1
4
1
1
1
1
1
1
1
* ENGINE, 23HP B&S ELS 2-CYL, Mod. 44L777-0125-B1
* ENGINE, 24HP B&S, ELS, Mod. 44M777-0113-E1
SCREW, TORX HEAD 5/16-18 X 5/8 YZ
EXHAUST TUBE SINGLE
EXHAUST TUBE RH
(not shown)
2
3
720663
727816
725220
725221
1727817
1722955
720045
720664
7500533Z
7101543
7101706
7101323
722861
728664
722866
722605
720183
721325
721180
7300662
all
21 H.P.
4
23 H.P. & 24 H.P.
5
EXHAUST TUBE LH
23 H.P. & 24 H.P.
6
THROTTLE ASSY, DUAL LEVER
THROTTLE, SINGLE (not shown)
HHST, 3/8-16X1.25
23 H.P. & 24 H.P.
6
21 H.P.
7
all
8
WASHER, 5/16-18 HEX HEAD
ASSY - HEAT SHIELD
all
9
all
10
11
12
13
14
15
16
17
18
19
20
ADAPTER - ELECTRIC PTO
CLUTCH, ANCHOR PAD
all
all
CLUTCH, ELECTRIC OGURA
SCREW - THREAD FORMING, 0.88 X 3/16-15
BRKT - MUFFLER
all
all
all
SCREW .25-20 X0.59 HEX
WASHER .470- 1.00.25 FLT
WASHER, .43-.074 X .04 STAR
MUFFLER - SINGLE
all
all
all
21 H.P.
MUFFLER
23 H.P. & 24 H.P.
23 H.P.
GUARD, HEAT SHIELD (EURO)
Footnotes:
NOTE: * Purchase engine parts from engine manufacturer dealer.
HYDRO DRIVE ELECTRIC CLUTCH
Manual No.
7006261
LT-100 SERIES
21
TP 400-5330-C-TC-N
46" Mower Housing Assembly
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
22
46" Mower Housing Assembly
Item Part No
Qty Description
Note
1
2
7300671
722397
1
3
2
2
3
1
MOWER DECK HOUSING, 46”
NUT-NYLOCK RING - PULLEY 9/16-18
S.S. PULLEY 46”
3A 726069
3B 7101744
PULLEY
4
5
721447
726958
JACKSHAFT HOUSING ASSY
SHAFT, SPLINED
(per Jackshaft Housing
Assembly)
6
7
8
726957
726959
721095
2
1
1
BALL BEARING, JACKSHAFT
JACKSHAFT HOUSING
(per Jackshaft Housing
Assembly)
(per Jackshaft Housing
Assembly)
FITTING - LUBRICATION (1/4-28 Self-Tap)
(per Jackshaft Housing
Assembly)
9
720097
726498
722511
720049
726831
720139
720142
722485
726830
720045
728320
7400226
720091
720989
721308
721310
722858
720145
727317
725149
721309
722512
728319
721446
725179
720658
722601
722600
2
2
1
19
1
3
2
1
1
15
1
1
5
1
1
1
4
6
1
1
1
1
1
2
3
3
3
3
SHOULDER BOLT, 3/8-16X1.06
PLATE SUSPENSION
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
SPRING, TORSION RH
BOLT CARRIAGE, 5/16-18 X .62
BRACKET, RIGHT REAR
HEX NUT, 5/16-18 FLANGE SER YZ
NUT, HEX FLANGE, 3/8-16 NC
SPRING
BRACKET, BELL CRANK
HHST, 3/8-16X1.25
BRACKET, COVER
ASSY - IDLER ARM, 46”, RH
SHOULDER BOLT, 0.75 X 0.60 X 3/8-16
GUIDE, BELT
BRACKET - BRAKE MTG 46'
BRACKET, BRAKE PLATE
CAPSCREW 5/16-18
NUT, HEX FLANGE LOCK, 5/16-18 NC
BRACKET, LEFT GAUGE WHEEL
BRACKET, PULLEY COVER
BRACKET, LEFT LIFTER
SPRING, TORSION RH
BRACKET, HINGE
SPACER, PULLEY
BLADE ADAPTER
BLADE (15.68")
WASHER-BELLEVILLE 1.0 X .625 X .200
WASHER - HARDENED 1.0OD X .625ID X .188
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
23
46" Mower Housing Assembly
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
24
46" Mower Housing Assembly
Item Part No
Qty Description
Note
37
38
39
40
41
42
722382
720908
721364
728906
720053
720372
3
2
1
1
1
1
NUT, BLADE, 9/16-18 ZINC PLATE YELLOW CHROMATE
GUIDE, SCREW
BRACKET, RIGHT GAUGE WHEEL
BRACKET, FRONT DECK
CARRIAGE BOLT
BOLT RETAINER
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
25
46" Mower Deck Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
26
46" Mower Deck Group
Item Part No
Qty Description
Note
1
721222
720161
721250
721402
725226
722579
720069
720098
725230
720142
721313
722871
721315
729075
720416
720404
720148
725225
720091
7500566
727459
720163
720387
722441
721311
722510
725171
725167
7400227
7500565
720392
720173
721118
721197
721376
721263
722858
2
2
2
2
2
3
2
2
2
6
1
3
1
2
1
1
2
1
3
1
1
1
1
1
1
2
1
2
1
1
2
2
2
2
2
1
2
KNOB
2
WASHER FLAT, 1.0 X .328 X 16GA
FRICTION PAD
3
4
PIN - HANGER 3/8-16 X 1.25
LINK, LIFT
5
6
WASHER - FLAT, 1.0”OD X 0.550”
HAIR PIN, .56D-.092T
7
8
SHOULDER BOLT, 3/8-16 X .600OD X.95L
BRACKET, REAR SUSPENSION
NUT, HEX FLANGE, 3/8-16 NC
COVER, LEFT PULLEY
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
SCREW
COVER, RIGHT PULLEY
SCREW, THREAD FORMING 10-24X.340MIN THREADS
BELT, PRIMARY (88.30" HA) 46” MOWER
BELT, SECONDARY (47.10" HA) 46” MOWER
NUT FLANGE, 3/8-16 ZINC PLATED
PULLEY IDLER
SHOULDER BOLT, 0.75 X 0.60 X 3/8-16
BRAKE ASSEMBLY CENTER
LINK BELLCRANK
FW, .34X.62X16GA
PIN - COTTER, 0.75 X 0.090
SPRING
BELLCRANK
SPRING, TORSION BRAKE
PULLEY BACKSIDE IDLER, 4.0 OD
SPACER 1/2” TO 17MM
ASSY - IDLER ARM, 46”
ASSY - BRAKE LH 46”
CLIP - HAIR PIN
WASHER, FLAT, .81 X .550 X 16GA
WHEEL GAGE
BOLT AXLE, 3/8-16 X 3.0
ROD, DECK SUSPENSION
ROD, HANGER
CAPSCREW 5/16-18
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
27
46" Mower Deck Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
28
46" Mower Deck Group
Item Part No
Qty Description
Note
38
39
40
41
42
43
44
45
46
721346
721312
720390
721453
720983
720982
720360
722504
721017
1
1
1
1
1
1
1
1
1
BRACKET, FRONT SUSPENSION
STIFFENER
COTTER PIN
ROLLER
DEFLECTOR, INSIDE
DEFLECTOR, CHUTE
CAP, PUSH ON
SPRING - TORSION
ROD, DEFLECTOR
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
29
50" Mower Housing Assembly
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
30
50" Mower Housing Assembly
Item Part No
Qty Description
Note
1
2
726814
722858
720049
720139
720145
726824
720097
726498
722511
722512
726373
720142
728319
727152
726473
726823
721457
721336
726790
721399
1
4
BLADE HOUSING 50/52
CAPSCREW 5/16-18
3
26
20
3
BOLT CARRIAGE, 5/16-18 X .62
HEX NUT, 5/16-18 FLANGE SER YZ
NUT, HEX FLANGE LOCK, 5/16-18 NC
BRACKET GAGE WHEEL RH REAR
SHOULDER BOLT, 3/8-16X1.06
PLATE SUSPENSION
4
5
6
1
7
2
8
2
9
1
SPRING, TORSION RH
10
11
12
13
14
15
16
17
18
19
20
1
SPRING, TORSION RH
1
BRACKET LIFTER RH 50”
NUT, HEX FLANGE, 3/8-16 NC
BRACKET, HINGE
2
1
1
BRACE LH LIFTER
1
BRACKET LIFTER LH
1
BRACKET GAGE WHEEL LH REAR
BRACKET GAGE WHEEL 52”
BRACKET FRONT DECK 50”
BAFFLE 48/52 RH BOTTOM
BRACKET CHUTE SUPPORT
2
1
1
1
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
31
50" Deck Blade Drive Assembly
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
32
50" Deck Blade Drive Assembly
Item Part No
Qty Description
Note
1
2
3
7500607
721447
721446
1
3
1
ASSY, MOWER HOUSING 48/50/52”
JACKSHAFT HOUSING ASSY
SPACER, PULLEY
(per Jackshaft Housing
Assembly)
4
5
6
7
726957
726958
726959
721095
2
1
1
1
BALL BEARING, JACKSHAFT
SHAFT, SPLINED
(per Jackshaft Housing
Assembly)
(per Jackshaft Housing
Assembly)
JACKSHAFT HOUSING
(per Jackshaft Housing
Assembly)
FITTING - LUBRICATION (1/4-28 self-Tap)
(per Jackshaft Housing
Assembly)
8
720142
725179
721334
722600
722382
720192
7090122
721385
7300924
720148
720139
720049
7300923
720091
726842
726855
726069
726507
721313
722871
722859
721315
720045
728320
722438
7400265
725167
725225
721081
725149
1
3
3
6
3
1
1
1
1
1
2
2
1
1
1
1
4
3
1
3
2
1
15
1
1
1
1
1
1
1
NUT, HEX FLANGE, 3/8-16 NC
BLADE ADAPTER
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
BLADE 50/52 (17.66")
WASHER - HARDENED 1.0OD X .625ID X .188
NUT, BLADE, 9/16-18 ZINC PLATE YELLOW CHROMATE
BOLT, HEX, 3/8-16 UNC X 1.50 BRIGHT ZINC
WASHER, 3/8” Flat SAE
PULLEY BACKSIDE IDLER
ARM - IDLER
ref. 725117 & 7300922)
NUT FLANGE, 3/8-16 ZINC PLATED
HEX NUT, 5/16-18 FLANGE SER YZ
BOLT CARRIAGE, 5/16-18 X .62
BRACKET - BRAKE MOUNTING
SHOULDER BOLT, 0.75 X 0.60 X 3/8-16
BELT SECONDARY 52.75" HA
V-BELT A WEDGE 103.10 HA
S.S. PULLEY 46”
ref. 726514
ref. 1734048
NUT PULLEY
COVER, LEFT PULLEY
SCREW
SCREW THREAD FORMING
COVER, RIGHT PULLEY
HHST, 3/8-16X1.25
BRACKET, COVER
SPRING, EXTENSION
ASSEMB-IDLER ARM 50”
SPACER 1/2” TO 17MM
(was 721338)
PULLEY IDLER
ROD BELT GUIDE
BRACKET, PULLEY COVER
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
33
50" Deck Housing Suspension Assembly
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
34
50" Deck Housing Suspension Assembly
Item Part No
Qty Description
ASSY, BLADE DRIVE 50/52”
Note
7500606
1
2
2
2
2
8
2
2
4
4
6
4
2
1
1
1
4
1
1
2
2
1
1
4
1
2
721380
720161
721402
728667
720142
720098
721212
721197
721118
722579
720392
720360
721017
720982
721453
722858
728665
720390
721376
720069
721263
721312
720185
WINGNUT
WASHER FLAT, 1.0 X .328 X 16GA
PIN - HANGER 3/8-16 X 1.25
LINK, LIFT
3
4
ref. 7300921D
ref. 7300826D
5
NUT, HEX FLANGE, 3/8-16 NC
SHOULDER BOLT, 3/8-16 X .600OD X.95L
BRACKET, REAR SUSPENSION
BOLT AXLE, 3/8-16 X 3.0
WHEEL GAGE
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
WASHER - FLAT, 1.0”OD X 0.550”
CLIP - HAIR PIN
CAP, PUSH ON
ROD, DEFLECTOR
DEFLECTOR, CHUTE
ROLLER
CAPSCREW 5/16-18
BRACKET, SUSPENSION FRONT
COTTER PIN
ref. 7300767D
ref. 7300871D
ROD, DECK SUSPENSION
HAIR PIN, .56D-.092T
ROD, HANGER
STIFFENER
WASHER
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
35
52" Mower Housing Assembly
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
36
52" Mower Housing Assembly
Item Part No
Qty Description
Note
1
2
726814
722858
720049
720139
720145
726824
720097
726498
722511
722512
726373
720142
728319
727152
726473
726823
721457
721336
726790
721399
1
4
BLADE HOUSING 50/52
CAPSCREW 5/16-18
3
26
20
3
BOLT CARRIAGE, 5/16-18 X .62
HEX NUT, 5/16-18 FLANGE SER YZ
NUT, HEX FLANGE LOCK, 5/16-18 NC
BRACKET GAGE WHEEL RH REAR
SHOULDER BOLT, 3/8-16X1.06
PLATE SUSPENSION
4
5
6
1
7
2
8
2
9
1
SPRING, TORSION RH
10
11
12
13
14
15
16
17
18
19
20
1
SPRING, TORSION RH
1
BRACKET LIFTER RH 50”
NUT, HEX FLANGE, 3/8-16 NC
BRACKET, HINGE
2
1
1
BRACE LH LIFTER
1
BRACKET LIFTER LH
1
BRACKET GAGE WHEEL LH REAR
BRACKET GAGE WHEEL 52”
BRACKET FRONT DECK 50”
BAFFLE 48/52 RH BOTTOM
BRACKET CHUTE SUPPORT
2
1
1
1
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
37
52" Deck Blade Drive Assembly
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
38
52" Deck Blade Drive Assembly
Item Part No
Qty Description
Note
1
2
3
7500607
721447
721446
1
3
1
ASSY, MOWER HOUSING 48/50/52”
JACKSHAFT HOUSING ASSY
SPACER, PULLEY
(per Jackshaft Housing
Assembly)
4
5
6
7
726957
726958
726959
721095
2
1
1
1
BALL BEARING, JACKSHAFT
SHAFT, SPLINED
(per Jackshaft Housing
Assembly)
(per Jackshaft Housing
Assembly)
JACKSHAFT HOUSING
(per Jackshaft Housing
Assembly)
FITTING - LUBRICATION (1/4-28 self-Tap)
(per Jackshaft Housing
Assembly)
8
720142
725179
721334
722600
722382
720192
7090122
721385
7300924D
720148
720139
720049
7300923
720091
726842
1734048
726069
726507
721313
722871
722859
721315
720045
728320
722438
7400265
725167
725225
721081
725149
1
3
3
6
3
1
1
1
1
1
2
2
1
1
1
1
4
3
1
3
2
1
15
1
1
1
1
1
1
1
NUT, HEX FLANGE, 3/8-16 NC
BLADE ADAPTER
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
BLADE 50/52 (17.66")
WASHER - HARDENED 1.0OD X .625ID X .188
NUT, BLADE, 9/16-18 ZINC PLATE YELLOW CHROMATE
BOLT, HEX, 3/8-16 UNC X 1.50 BRIGHT ZINC
WASHER, 3/8” Flat SAE
PULLEY BACKSIDE IDLER
ARM - IDLER
ref. 725117 & 7300922)
NUT FLANGE, 3/8-16 ZINC PLATED
HEX NUT, 5/16-18 FLANGE SER YZ
BOLT CARRIAGE, 5/16-18 X .62
BRACKET - BRAKE MOUNTING
SHOULDER BOLT, 0.75 X 0.60 X 3/8-16
BELT SECONDARY 52.75” HA
V-BELT A WEDGE 103.10" HA
S.S. PULLEY 46”
ref. 726514
ref. 726855 -52
NUT PULLEY
COVER, LEFT PULLEY
SCREW
SCREW THREAD FORMING
COVER, RIGHT PULLEY
HHST, 3/8-16X1.25
BRACKET, COVER
SPRING, EXTENSION
ASSEMB-IDLER ARM 50”
SPACER 1/2” TO 17MM
(was 721338)
PULLEY IDLER
ROD BELT GUIDE
BRACKET, PULLEY COVER
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
39
52" Deck Housing Suspension Assembly
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
40
52" Deck Housing Suspension Assembly
Item Part No
Qty Description
ASSY, BLADE DRIVE 50/52”
Note
7500606
1
2
2
2
2
8
2
2
4
4
6
4
2
1
1
1
4
1
1
2
2
1
1
4
1
2
721380
720161
721402
7300921D
720142
720098
7300826D
721197
721118
722579
720392
720360
721017
720982
721453
722858
7300767D
720390
721376
720069
721263
7300871D
720185
WINGNUT
WASHER FLAT, 1.0 X .328 X 16GA
PIN - HANGER 3/8-16 X 1.25
LINK, LIFT
3
4
5
NUT, HEX FLANGE, 3/8-16 NC
SHOULDER BOLT, 3/8-16 X .600OD X.95L
BRACKET, REAR SUSPENSION
BOLT AXLE, 3/8-16 X 3.0
WHEEL GAGE
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
WASHER - FLAT, 1.0”OD X 0.550”
CLIP - HAIR PIN
CAP, PUSH ON
ROD, DEFLECTOR
DEFLECTOR, CHUTE
ROLLER
CAPSCREW 5/16-18
BRACKET, SUSPENSION FRONT
COTTER PIN
ROD, DECK SUSPENSION
HAIR PIN, .56D-.092T
ROD, HANGER
STIFFENER
WASHER
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
41
Decals
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
42
Decals
Item Part No
Qty Description
DECAL, Snapper Name Plate, RH
Note
1
2
7102191
7102192
7101965
7102196
7102211
7101933
7101937
7102197
7102198
7102199
7101936
7102193
7102194
7102195
7101939
7101938
7101934
7101940
7101935
7101394
724017
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
DECAL, Snapper Name Plate, LH
DECAL, Ignition
3
4
DECAL, Snapper Logo, Rear
DECAL, Snapper Logo, Steering Wheel
DECAL, Operation
5
6
7
DECAL, Deck Level
8
DECAL, 19.5 hp (not shown)
DECAL, 23 hp
8
8
DECAL, 24 hp (not shown)
DECAL, Drive Pedal
9
10
10
10
11
12
13
14
15
16
17
DECAL, 46” Deck (not shown)
DECAL, 42” Deck (not shown)
DECAL, 52” Deck
DECAL, Belt/Clutch
DECAL, Height of Cut
DECAL, Park Brake
DECAL, Weight Limitation
DECAL, Roll Release
DECAL, Warning, Rear Discharge Door
DECAL, Gage Wheel Instruction
DECAL-Umber (not shown)
DECAL-No Step (not shown)
DECAL, Danger Do Not Operate w/o Deflector (not shown)
DECAL, Height of Cut Snapper (not shown)
DECAL, Deck Level (not shown)
DECAL, Gage Wheel Leveling (not shown)
7101663
7101664
7101665
7102210
724023
724026
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
43
Electrical Group
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
44
Electrical Group
Item Part No
Qty Description
HARNESS, WIRING, HYDRO TCT, ELEC PTO
Note
1
2
7101446
721516
721249
720123
720349
720057
720588
720348
7060618
1722887
7026343
727338
721461
722851
722393
721615
7023354
1726556
1726557
1727185
1
1
1
2
1
2
1
1
1
1
1
1
1
3
2
1
1
1
1
1
SWITCH, LIMIT, NO, SNAP-IN
SWITCH, LIMIT, NO/NC, SNAP-IN
WINGNUT, 1/4-20 NC-2 TAP
CABLE, BAT 8GA 12.00L - BLACK
CARRIAGE BOLT, 0.63L X 1/4-20 2A
BOOT, BATTERY POSITIVE
CABLE, BAT 8GA 18.00L - RED
BATTERY, 12 VOLT, 230 CCA
SWITCH, PTO, YELLOW, VERTICAL SYMBOLS
SWITCH, IGNITION-AFTERFIRE SOLENOID
CAP, IGNITION SWITCH
3
4
5
6
7
8
9
replaces 7100449
10
11
12
13
14
15
16
17
KEY, IGNITION
SCREW, 1/4-14X.38”ST
NUT, HEX LOCK 1/4-20 BZ
SOLENOID, 3 POLE
SWITCH, SEAT
SWITCH, REV MOW OPTION MODULE ONLY W/KEY
KEY (CHERRY)
(not shown)
(not shown)
(not shown)
KEY W/ HANG TAG
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
45
Wiring Schematic
Manual No.
7006261
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
TP 400-5330-C-TC-N
46
Wiring Schematic
Item Part No
Qty Description
Wiring Schematic for Harness # 7101446
Note
1
1
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-100 SERIES
Manual No.
7006261
TP 400-5330-C-TC-N
47
Parts Manual for
HYDRO DRIVE ELECTRIC CLUTCH
LAWN TRACTOR
LT-100 SERIES
IT IS THE POLICY OF BRIGGS & STRATTON CORP TO IMPROVE ITS
PRODUCTS WHENEVER IT IS POSSIBLE AND PRACTICAL TO DO SO.
WE RESERVE THE RIGHT TO MAKE CHANGES OR ADD
IMPROVEMENTS AT ANY TIME WITHOUT INCURRING ANY
OBLIGATION TO MAKE SUCH CHANGES ON PRODUCTS
McDonough, GA, 30253 U.S.A.
Briggs & Startton Yard Power Products Group
Manual No.
7006261
Copyright © 2008
Briggs & Startton Corporation
Milwaukee, WI USA. All Rights Reserved
Revision C, 1/30/2008
TP 400-5330-C-TC-N
|