Parts Manual for
HYDRO DRIVE ZTR
350Z/400Z
SERIES 1
MODEL
ZT18441KHC (5900608)
ZT19441KWV (5900609)
ZT20501BV (5900610)
EZT20501BV (5901166)
400ZB2450 (5900706)
McDonough, GA, 30253 U.S.A.
Briggs & Startton Yard Power Products Group
Manual No.
7006937
Copyright © 2007
Briggs & Startton Corporation
Milwaukee, WI USA. All Rights Reserved
Revision F, 10/15/2007
TP 400-5132-F-HZ-N
Table Of Contents
PAGE
4
GROUP
Wheel & Tire Group
Main Frame & Front Suspension Group
Seat & Kickplate Group
6
8
Seat & Kickplate Group - 24 HP Models
Fuel Tank Group
10
12
14
16
18
20
24
26
28
30
32
34
36
38
40
42
44
48
50
54
56
58
60
62
64
Control Group Upper
Control Group Lower
Drive Group
Brake Group
Hydraulic Group (270HYD1)
Hydraulic Pump SERVICE PARTS - BDP/PG Series
Engine & PTO Group - BRIGGS & STRATTON
Engine & PTO Group - 24 HP Briggs & Stratton
Engine & PTO Group - KAWASAKI
Engine & PTO Group - KOHLER
Bumper Group
Decals Group - Brand & Model
Decals Group - Safety & Common
Export Decals Group - Safety & Common
Lift Group
44" & 50" Mower Deck - Belt & Idler Group
44" & 50" Mower Deck - Housing, Arbors & Blades Group
44" & 50" Mower Deck Roller Group
Control Group Panel
Electrical Group
Wiring Schematic 18hp
Wiring Schematic 20hp
Wiring Schematic - 24 HP Briggs & Stratton
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
3
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
4
Wheel & Tire Group
Item Part No
Qty Description
Note
1
2
5022433S
5022433X1
5022433S2
2172353
2
2
2
4
4
4
2
2
2
2
2
2
8
4
WHEEL & TIRE ASSEMBLY, 11 X 4.0 - 5, COMPLETE
TIRE, FRONT, 11 X 4.0 - 5
(Includes Ref No. 2 - 6)
3
WHEEL ASSEMBLY, COMPLETE
VALVE STEM & CAP ASSEMBLY
BEARING, ROLLER
(Includes Ref No. 4 & 5)
4
5
5021042
(2 Per Tire)
(2 Per Tire)
6
5021043
BEARING RETAINER
7
5045996
AXLE, FRONT CASTER
8
5025017X52
5025056
BOLT, 1/2-13 X 6-1/2
9
NUT, HEX NYLON LOCK, 1/2-13
WHEEL & TIRE ASSEMBLY, 20 X 8.0 - 10, COMPLETE
TIRE, REAR, 20 X 8.0 X 10
10
11
12
13
14
5023095
(Includes Ref No. 4, 11 & 12)
5023095X1
5023095X2
5020601
WHEEL ASSEMBLY, FOR 20 X 8.0 X 10 TIRE
LUG NUT, 1/2-20
5025158
WASHER, SAE, 1/2
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
5
Main Frame & Front Suspension Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
6
Main Frame & Front Suspension Group
Item Part No
Qty Description
NUT 5/16-18 HEX NYLON LOCK
Note
1
2
5025057
5025265X56
5025160
5025284
5025303
5020095
5022852
5047489
5400756
5023214
5045990
5021541
5020602
5048775D
5400405D
5400350D
5100358
5025392
5401053D
5025155
5025011X6
5403499D
8
1
1
1
8
2
1
1
1
2
2
4
2
2
1
1
1
4
2
4
4
1
3/4-16 X 7” GD 8 BOLT TZ
3
WASHER, 3/4” SAE
4
NUT, 3/4-16 HEX NYLON LOCK
SCREW 5/16-18 X 1 FLAT HD SC
GREASE FITTING, 1/4-28 STR
PIVOT BEARING,1.00” X 1.125” OD X 1.50”
SPACER, .75 X 1.00 X 2.38
SPACER, .75 X 1.50 X .785
CAP, VINYL 1.687 X 1-1/2
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
PLATE, FRICTION REDUCER
BUSHING, FLANGE
COLLAR, 1” SPLIT
WELD, CASTER YOKE
WELD, PIVOTING FRONT END
WELD, MAIN FRAME, SNAPPER ZT
BEARING, PIVOT, 1.00 X 1.25 X .50
NUT, 5/16-18 HEX NYLOCK FLANGE
PLATE, DECK STOP - SNAPPER RED
WASHER, 5/16" SAE
BOLT, 5/16-18 X 3/4" GD5
WELD, MAIN FRAME, SNAPPER 400Z
(24 HP Models Only)
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
7
Seat & Kickplate Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
8
Seat & Kickplate Group
Item Part No
Qty Description
Note
1
2
7078299
2
8
6
6
6
6
4
1
8
1
1
1
1
1
1
1
SPRING, SEAT SUPPORT
NUT, 3/8-16 HEX NYLOCK FLANGE
BOLT, 3/8-16 X 1” GD5
5025394
3
5025013X8
5025392
4
NUT, 5/16-18 HEX NYLOCK FLANGE
BOLT, 5/16-18 X 1” GD5
WASHER, 5/16” GD.9 FLAT
NUT, 5/16-18 HEX NYLON LOCK
BOLT, 3/8-16 X 5” GD5
5
5025011X8
5025292
6
7
5025057
8
5025013X40
5025156
9
WASHER 3/8” SAE
10
11
12
13
14
15
16
5025013X32
5400528D
5061599
BOLT, 3/8-16 X 4” GD5
WELD, SEAT PLATE - RED
SEAT
5400361D
5049979
MOUNT, OIL FILTER
SAFETY WALK, FLOOR REST
SAFETY WALK, FLOOR PLATE
PLATE, FLOOR DETAIL
5049978
5400918D
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
9
Seat & Kickplate Group - 24 HP Models
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
10
Seat & Kickplate Group - 24 HP Models
Item Part No
Qty Description
MOUNT, OIL FILTER- RED
Note
1
5400361D
5025011X8
5025292
5025392
7078299
5025156
5100999
5101007
5061599
5025057
5025394
5403488D
5403665D
5403044D
35097
1
8
8
6
2
2
1
1
1
4
4
1
1
1
6
4
6
2
2
8
1
1
1
6
1
1
1
2
BOLT, 5/16-18 X 1 GD 5 YZ
3
WASHER, 5/16 GD. 9 FLAT
4
NUT, 5/16-18 HEX NYLOCK FLANGE
SPRING, SEAT SUPPORT
5
6
WASHER, 3/8 SAE
7
SAFETY WALK, FLOOR PLATE, 17.38 X 11.50
SAFETY WALK, FLOOR REST, 17.38 X 6.00
SEAT, XB-180, NO LOGO, BLACK
NUT, 5/16-18 HEX NYLON LOCK
NUT, 3/8-16 HEX NYLOCK FLANGE
WELD, SEAT PLATE - RED
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
PLATE, FLOOR, CONSUMER Z - RED
PLATE, FLOOR, FRONT, CONS Z - RED
MOUNT, VIBRATION, 30 DURO
MOUNT, VIBRATION, RUBBER
BOLT, 3/8-16 X 5/8, SERRATED UNDER HEAD
BOLT, 3/8-16 X 3-1/2 GD5 YZ
197546
5025481
5025013X28
5044617
5025128
5403372D
5025155
5025011X6
5025480
1686907
5100636
5061599X1
WASHER, .34 X 1.25 X 10 GA
NUT, 3/8-18 HEX SERRATED FLANGE
PLATE, SUPPORT, FRONT FLOOR - RED
WASHER, 5/16 SAE
BOLT, 5/16-18 X 3/4 GDS
WASHER, 3/8" ID, INTERNAL TOOTH
ARM REST, SET OF TWO (SV)
SPRING, SEAT ADJUSTMENT (SV)
KIT, SEAT RAILS. COMPLETE (SV)
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
11
Fuel Tank Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
12
Fuel Tank Group
Item Part No
Qty Description
Note
1
5025011X6
5025155
5025392
5025299X4
5025386
5025170
5025011X8
5048751
5048909D
5048763D
5400836D
5022158
5048752
5400919D
5023345
5023191
5023061
5600050
5050925X20
5023069
5023067
5023197
5022917X1
5025292
5300046
16
10
8
BOLT, 5/16-18 X 3/4” GRD5
2
WASHER, 5/16” SAE
3
NUT, 5/16-18 HEX NYLOCK FLANGE
SCREW, ALLEN HEAD, 1/4-20X1/2
SCREW, Allen Head, #10-24 x 3/8”
WASHER, 5/16” LOCK
4
2
5
6
6
10
4
7
BOLT, 5/16-18 X 1” GD5
FUEL TANK ASSEMBLY
PLATE, FUEL TANK BADGE - RED
BRACKET, REAR SUPPORT - RH - RED
BRACKET, REAR SUPPORT - LH - RED
CAP, FUEL TANK, 3-1/2” NECK
TANK, FUEL - RH
8
1
(Includes Ref. 17 - 23)
9
2
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
1
1
1
1
1
PLATE, SUPPORT, REAR TANK - RED
TANK, 2QT HYDRAULIC
CAP, HYDRAULIC RESERVOIR
ELBOW FITTING
1
1
1
Not Shown
Not Shown
Not Shown
Not Shown
Not Shown
Not Shown
Not Shown
1
GROMMET
1
HOSE, 20”
2
HOSE CLAMP
1
SCREEN FITTING
1
FUEL GAUGE
1
GROMMET
10
1
WASHER, GR. 9 FLAT
ASSM, FUEL HOSE
Not Shown (Includes Ref. 17 -
21)
26
27
5020835
2
1
CLAMP, HOSE, RED
5050831X20
HOSE, 1/4" FUEL LINE, 20" LONG
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
13
Control Group Upper
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
14
Control Group Upper
Item Part No
Qty Description
Note
1
5021098
2
2
4
6
4
4
2
4
4
2
4
2
8
12
8
4
4
1
1
2
2
1
1
8
2
2
BEARING, BRONZE FLANGE, 3/4”
BEARING, FLANGE
2
5021499
3
5025013X14
5025394
BOLT, 3/8-16 X 1-3/4” GD5
NUT, 3/8-16 HEX NYLOCK FLANGE
10-24 X .5 SCREW
4
5
5025179X4
5025029
6
NUT, HEX, #10-24
7
5025013X8
5025096
BOLT, 3/8-16 X 1” GD5
8
NUT, 3/8-16 HEX NYLON LOCK
3/8-16 x 1-1/4 SOCKET HD CAPSCR
BOLT, 5/16-18 X 2” GD 5 TFL
NUT, 5/16-18 HEX LG SERR FLG.
BOLT, 5/16-18 X 1.75” GD 5 TFL
BOLT, 5/16-18 X 2-1/2” GD5
WASHER, 5/16” SAE
9
5025327
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
5025055X16
5025139
5025055X14
5025011X20
5025155
5025392
NUT, 5/16-18 HEX NYLOCK FLANGE
WASHER, 5/16” LOCK
5025170
5025011X8
5401020D
5401017D
5022068
BOLT, 5/16-18 X 1” GD5
WELD, CONTROL SHAFT- RH
WELD, CONTROL SHAFT- LH
GRIP, FOAM, 3/4” ID, 16” LONG
MOUNT, CONTROL ARM
5047004
5401096D
5401097D
5048264
WELD, HANDLE MOTION CONTROL-LH
WELD, HANDLE MOTION CONTROL-RH
SPACER, .63 X .39 X 1.50
5048169D
5022095
WELD, NEUTRAL PLATE
SWITCH, PLUNGER, N.O. / N.C.
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
15
Control Group Lower
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
16
Control Group Lower
Item Part No
Qty Description
Note
1
5010546
5025214X8
5025211
5023242
5023260
5025057
5025011X10
5025155
5025033
5025045
5025011X8
5023212
5025335
5025354
5025355
5022645
5020047
5021171
5049969
5022978
5022628
5021146
5048921
5048923
5025035
2
2
2
2
2
4
2
6
2
2
2
2
4
4
4
2
2
2
2
2
2
2
2
2
2
COLLAR, 3/8” SET
2
PIN, CLEVIS, 3/8” X 1”
3
PIN, HAIR, .0585 X 1-1/8
SPRING, CONTROL ROD
BUSHING, FLANGE 3/8ID X 7/8 LONG
NUT 5/16-18 HEX NYLON LOCK
BOLT, 5/16-18 X 1-1/4” GD5
WASHER, 5/16” SAE
4
5
6
7
8
9
NUT, HEX 5/16-24
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
NUT 5/16-24 HEX NYLON LOCK
BOLT, 5/16-18 X 1” GD5
NUT, 5/16 HEX LH
BOLT, M8-1.25 x 35MM
NUT, M8-1.25 Hex Nylon Lock
NUT, M8-1.25 Hex Serrated Flange
SPRING, COMPRESSION
SET COLLAR, 5/16”
CLEVIS, 3/8-24, PLASTIC
ROD, NEUTRAL CONTROL, 8”
DAMPENER
BALL JOINT, 5/16-24 Female LH
BALL JOINT, 5/16-24 Female
CONTROL ROD, ADJ. SPRING
ROD ASSEMBLY, SLIDER
NUT, 3/8-24 HEX
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
17
Drive Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
18
Drive Group
Item Part No
Qty Description
BOLT, 3/8-16 X 4” GD5
Note
1
5025013X32
5025305
1
2
1
3
5
1
1
2
2
2
1
2
1
1
1
1
2
2
1
1
2
1
1
1
1
1
4
2
WASHER, .41 X 1.75 X .14
BOLT, 3/8-16 X 2” GD5
3
5025013X16
5025156
4
WASHER 3/8” SAE
5
5025394
NUT, 3/8-16 HEX NYLOCK FLANGE
BOLT, 3/8-16 X 2-1/2” GD5
BOLT, 3/8-16 X 1-3/4” GD5
WASHER, .265 X 1.50 X .109, YZ
WASHER, 1/4” LOCK
6
5025013X20
5025013X14
5044577
7
8
9
5025169
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
5023215
BOLT, M6-1.0 X 14MM
5025013X8
5025034
BOLT, 3/8-16 X 1” GD5
NUT, 3/8-16 HEX
5022931
BELT, DECK DRIVE
5023497
EYE BOLT, 3/8-16 X 5”, 1” EYE
PULLEY, IDLER
5021002
5049184
SPACER, HYDRO IDLER PULLEY
KEY, 5MM SQ W/ RADIUS
BUSHING, BRASS, 1.25 X 1 X 1.25
SPACER, .39 X 1.00 X 2.55
PLATE, ANCHOR, SPRING
PULLEY, PUMP DRIVE
5023254
5022157
5045135
5048219D
5023251
1715435
SPRING, EXTENSION, 1.00
PULLEY, IDLER, SINGLE FLANGE
WELD, ARM, PUMP DRIVE IDLER
WELD, ANCHOR EYEBOLT
PULLEY, Crankshaft
5022621
5046430D
5045200D
5023252
5025061X2
SET SCREW, 5/16-18 X 1/2
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
19
Brake Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
20
Brake Group
Item Part No
Qty Description
BEARING, BRONZE FLANGE, 3/4”
Note
1
5021098
4
11
4
1
2
2
2
2
1
1
1
4
4
2
4
1
4
4
2
1
2
12
12
1
2
1
3
2
2
2
4
1
1
1
1
2
2
2
5025394
NUT, 3/8-16 HEX NYLOCK FLANGE
BOLT, 3/8-16 X 3/4” GD5
NUT, 3/8-16 HEX
3
5025013X6
5025034
4
5
5025126
NUT, 1/4-20 HEX SERR. FLANGE
WASHER, 1/4” SAE
6
5025154
7
5025010X5
5048401D
5025058X16
5025203X6
5025214X8
5025011X8
5025392
BOLT, 1/4-20 X 5/8” GD5
WELD, MOUNT BRAKE LEVER
BOLT, 3/8-16 X 2” GD 5 TFL CZ
PIN, COTTER, 1/8" X 3/4"
PIN, CLEVIS, 3/8” X 1”
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
BOLT, 5/16-18 X 1” GD5
NUT, 5/16-18 HEX NYLOCK FLANGE
WASHER, 5/16” SAE
5025155
5025075X6
5048163D
5025010X12
5025287
BOLT, 3/8-16 X 3/4", ALLEN BUTTON
WELD, SHAFT BRAKE LEVER
BOLT, 1/4-20 X 1-1/2” GD5
NUT, 1/4-20 HEX SIDE LOCK
NUT, HEX 3/8-24
5025035
5025013X16
5025128
BOLT, 3/8-16 X 2” GD5
NUT, 3/8-16 HEX LG. SERR FLG
BOLT, M6-1.0 X 14MM
5023215
5025169
WASHER, 1/4” LOCK
5048166D
5022182
WELD, SHAFT, REAR BRAKE
SWITCH PLUNGER NO/NC SNAP IN
HANDLE, BRAKE LEVER
WELD, PIVOT LINKAGE MOUNT
SPACER, .38 X .50 X .27
DRUM, BRAKE, 4-BOLT
CLEVIS, 3/8-24 PLASTIC
COLLAR, 3/8” SET
5045619D
5045618D
5041930
5023094
5021171
5010546
5023106
BRAKE ASSEMBLY, RH
BRAKE ASSEMBLY, LH
(Not Shown)
5023188
5045621D
5100171
BRACKET, SWITCH MOUNT
GRIP, BLACK FLEXIBLE
SPRING, BRAKE
5022361
5047091
ROD, BRAKE ADJUSTMENT
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
21
Brake Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
22
Brake Group
Item Part No
Qty Description
Note
38
39
5047084D
5042553
2
1
LINK, BRAKE LOCK
ROD, BRAKE ENGAGEMENT 36”
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
23
Hydraulic Group (270HYD1)
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
24
Hydraulic Group (270HYD1)
Item Part No
Qty Description
Note
1
5023191
1
1
1
1
1
1
4
4
2
4
10
1
4
1
1
1
1
3
1
2
2
2
1
1
8
8
4
4
2
2
2
CAP
2
5023345
HYDRAULIC TANK
3
5021164
CLAMP, #10 HOSE STAINLESS
HOSE, 3/8 X 8.50” LONG
TEE FITTING
4
5050860X8P
5022920
5
6
5050860X27
5022710
HOSE, 3/8 X 27” LONG
25.5” HOSE ASSEMBLY
FITTING, ADAPTER
7
8
5022634
9
5023091
WHEEL MOTOR
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
5023267
FITTING, 90 DEG. O-RING
CLAMP, HOSE
5023268
5100072
HYDRAULIC PUMP, LH (PG1HQQ-DV1X-XXXX)
FITTING, ADAPTER
Was 5023092
5023338
1719168
FILTER
5023096
FILTER HEAD
5400707
HOSE, 5/8 X 12.5” LONG
FITTING, TEE
5023266
5050860X7P
5100073
HOSE, 3/8 X 7.5 “ LONG
HYDRAULIC PUMP, RH (PG1KQQ DV1X-XXXX)
KEY
Was 5023093
5023091X1
5023091X2
5025203X10
5023346
NUT, CASTLE
PIN, COTTER, 1/8 X 1-1/4
ADAPTER, 90 DEG, 9/16-5/8 BARB
CLAMP, HOSE 7/8
5061549
5025013X8
5025171
BOLT, 3/8-16 X 1" GD5 YZ
WASHER, 3/8" SPLIT LOCK
BOLT, 3/8-16 X 1-1/4" GD5
NUT, 3/8-16 HEX SERRATED FLANGE
BOLT, 1/4-20 X 3/4" GD5 YZ
WASHER, 1/4" SAE
5025013X10
5025128
5025010X6
5025154
5025169
WASHER, 1/4" LOCK
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
25
Hydraulic Pump SERVICE PARTS - BDP/PG Series
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
26
Hydraulic Pump SERVICE PARTS - BDP/PG Series
Item Part No
Qty Description
Note
1
2
5023405
5023406
1
1
Housing Kit
End Cap Kit (W/ Poppets, Standard Charge) (Includes Ref. Nos.
66)
3
4
5
6
7
5023407
5023408
5023409
5023410
--
1
4
1
1
1
Straight Headless Pin
Hex Flange Bolt M8-1.25 X 60mm LG
Housing O-Ring
Charge Pump Kit (STD) (Includes Ref. Nos. 7 & 8)
STD Gerotor Assy (11 cu. In/rev D-Drive) (Not a Serviceable
Part)
Not a serviceable part.
8
--
1
2
1
1
O-Ring (Not a Serviceable Part)
10
15
18
5023411
5023412
5023413
Socket Head Screw M6 x 1.0-20mm Lg (STD Charge)
Bypass Valve Kit (Blank)
Pump Shaft Kit (Blind 15mm Keyway W/ Std Charge) (Includes
Ref. Nos. 19)
19
20
21
22
25
29
30
31
32
34
37
38
42
44
49
56
66
--
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
2
1
1
1
1
Ball Bearing 17 x 40 x 12 (Not a Serviceable Part)
Lip Seal 17 x 40 x 7 PTC
Not a serviceable part.
5023414
5023415
5023416
5023417
5023418
5023419
5023420
5023421
5023422
5023423
5023424
5023425
5023426
5023427
5023428
--
Spacer
Retaining Ring
Cylinder Block Kit
Block Spring
Block Thrust Washer
Valve Plate (Steel N-Tec:Black)
Swashplate
Ball Thrust Bearing
Trunnion Arm, Tapered Square
Slot Guide
Check Valve Kit (0.031”Orifice)
Charge Relief Valve Kit (1/4” Plastic Ball & Spring)
Trunnion Seal / Retainer Kit
Straight Thread Plug
5/16” SAE Plug (Not a Serviceable Part)
Overhaul Seal Kit
Not a serviceable part.
Not Shown
100 5023429
101 --
Spacer RTN (Not a Serviceable Part)
Spring, Extension (Not a Serviceable Part)
Screw, 5/16 x .875 (Patch) (Not a Serviceable Part)
Washer .34 x .88 x .06 (Not a Serviceable Part)
Washer, Nylon (Not a Serviceable Part)
Nut, Hex Lock 5/16-24 UNF (Not a Serviceable Part)
Spacer (Not a Serviceable Part)
Not a serviceable part.
Not a serviceable part.
Not a serviceable part.
Not a serviceable part.
Not a serviceable part.
Not a serviceable part.
Not a serviceable part.
102 --
103 --
104 --
105 --
106 --
107 --
110 5023430
Kit, RTN, STD (Includes Ref. Nos. 94, 98, 100, 101, 102, 103,
104, 104, 105, 106 & 107)
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
27
Engine & PTO Group - BRIGGS & STRATTON
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
28
Engine & PTO Group - BRIGGS & STRATTON
Item Part No
Qty Description
* ENGINE, 20HP B&S Model 358777-0280-E1
Note
1
2
--
1
1
6
6
13
2
7
3
1
1
1
1
1
1
1
4
1
3
1
1
1
1
5023187
5025392
5025011X6
5025155
5048262D
5025057
5044617
5043636
5050407X18
5023100
5042132
5023253
5021030
5048226D
5025011X14
5025188
5025011X8
5401071D
5048681
5050833X6
5021500
MUFFLER
3
NUT, HEX NYLOCK FLANGE, 5/16-18
BOLT, 5/16-18 X 3/4
4
5
WASHER, SAE, 5/16
6
BRACKET, MUFFLER SUPPORT
NUT, HEX NYLON LOCK, 5/16-18
WASHER, CLUTCH ANCHOR, 5/16
CLUTCH ANCHOR PAD
KEY, 1/4 SQ. X 2-1/4
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
CLUTCH, ELECTRIC
SPACER, .45 X 1.62 X .37
BOLT, CRANKSHAFT, 7/16 X 3-1/4
TIE WRAP
CLUTCH ANCHOR
BOLT, 5/16-18 X 1-3/4
WASHER, 5/16 INT TOOTH LOCK
BOLT, 5/16-18 X 1
PLATE, HEAT SHIELD
HOSE, OIL DRAIN
(Not Shown)
(Not Shown)
(Not Shown)
WIRE LOOM, OIL DRAIN
CLAMP, VINYL INSULATED
Footnotes:
Note: * See your local Briggs & Stratton distributor for parts & service.
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
29
Engine & PTO Group - 24 HP Briggs & Stratton
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
30
Engine & PTO Group - 24 HP Briggs & Stratton
Item Part No
Qty Description
* ENGINE-24HP B&S, ELS #44M777-0113-E1
Note
1
--
1
1
1
3
1
1
7
10
11
1
4
4
1
1
1
1
1
1
1
1
1
1
2
4
2
2
5023100
5043636
5044617
5023253
5042132
5025011X8
5025155
5025392
5050407X18
5025011X18
5025188
5048681
5100907
5100969
5401071D
5021500
5025010X6
5025391
5048226D
792105
CLUTCH, ELECTRIC, 1" SHAFT
CLUTCH ANCHOR PAD
3
4
WASHER, .34 X 1.25 X 10GA
BOLT, CRANKSHAFT, 7/16-20 X 3-1/4" YZ
SPACER, .45 X 1.62 X .37
BOLT, 5/16-18 X 1" GD5
WASHER, 5/16" SAE
5
6
7
8
9
NUT, 5/16-18 HEX NYLOCK FLANGE
KEY, 1/4" SQ. X 3-1/2"
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
BOLT, 5/16-18 X 2-1/4" GD5
WASHER, 5/16" INT. TOOTH LOCK
HOSE, OIL DRAIN
MUFFLER, 22HP B&S - ELS - IS500Z
EXTENSION, TAILPIPE, 3"
PLATE, HEAT SHIELD
CLAMP, VINYL INSULATED
BOLT, 1/4-20 X 3/4" GD5
NUT, 1/4-20 HEX NYLOCK FLANGE
ANCHOR, CLUTCH
AIR CLEANER W / PRE CLEANER (SV)
PRE CLEANER (SV)
(INCLUDES REF. NO. 22)
792303
273485
GASKET, EXHAUST
94480
SCREW, SEM HEX HEAD
SCREW
5021808X8
Footnotes:
NOTE* Purchase engine parts from engine manufacturer dealer.
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
31
Engine & PTO Group - KAWASAKI
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
32
Engine & PTO Group - KAWASAKI
Item Part No
Qty Description
* ENGINE, 19HP KAWASAKI
Note
1
2
--
1
1
6
6
13
2
7
3
1
1
1
1
1
1
1
4
1
3
1
1
1
1
2
5101125
5025392
5025011X6
5025155
5044933
5025057
5044617
5043636
5050407X18
5023100
5042132
5023253
5021030
5048226D
5025011X14
5025188
5025011X8
5400870D
5048681
5050833X6
5021500
5044960
MUFFLER
3
NUT, HEX NYLOCK FLANGE, 5/16-18
BOLT, 5/16-18 X 3/4
4
5
WASHER, SAE, 5/16
6
SPACER, .39 X .75 X .38
NUT, HEX NYLON LOCK, 5/16-18
WASHER, CLUTCH ANCHOR, 5/16
CLUTCH ANCHOR PAD
KEY, 1/4 SQ. X 2-1/4
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
CLUTCH, ELECTRIC
SPACER, .45 X 1.62 X .37
BOLT, CRANKSHAFT, 7/16 X 3-1/4
TIE WRAP
CLUTCH ANCHOR
BOLT, 5/16-18 X 1-3/4
WASHER, 5/16 INT TOOTH LOCK
BOLT, 5/16-18 X 1
PLATE, HEAT SHIELD
HOSE, OIL DRAIN
(Not Shown)
(Not Shown)
(Not Shown)
WIRE LOOM, OIL DRAIN
CLAMP, VINYL INSULATED
SPACER, .39 X 1.00 X .38
Footnotes:
Note: * See your local Kawasaki distributor for parts & service.
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
33
Engine & PTO Group - KOHLER
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
34
Engine & PTO Group - KOHLER
Item Part No
Qty Description
* ENGINE, 18HP KOHLER Model SV540S, PS-552725
Note
1
2
--
1
5
6
1
6
1
1
3
1
1
1
1
1
1
1
1
1
1
1
3
1
5025011X8
5025392
5025011X6
5025155
5025188
5025126
5044617
5043636
5050407X18
5023100
5042132
5023253
5021029
5048226D
5025011X14
5048681
5050833X6
5021500
5100399
5023236
BOLT, 5/16-18 X 1
3
NUT, HEX NYLOCK FLANGE, 5/16-18
BOLT, 5/16-18 X 3/4
4
5
WASHER, SAE, 5/16
6
WASHER, 5/16 INT TOOTH LOCK
NUT, 1/4-20 HEX SERR. FLANGE
WASHER, CLUTCH ANCHOR, 5/16
CLUTCH ANCHOR PAD
KEY, 1/4 SQ. X 2-1/4
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
CLUTCH, ELECTRIC
SPACER, .45 X 1.62 X .37
BOLT, CRANKSHAFT, 7/16 X 3-1/4
TIE WRAP, 11" LONG
CLUTCH ANCHOR
BOLT, 5/16-18 X 1-3/4" GD5 YZ
HOSE, OIL DRAIN
WIRE LOOM, OIL DRAIN
CLAMP, VINYL INSULATED
BOLT, 3/8-16 X 1", SELF-TAPPING
GROMMET, 3/4"
Footnotes:
Note: * See your local Kohler distributor for parts & service.
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
35
Bumper Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
36
Bumper Group
Item Part No
Qty Description
Note
1
2
3
4
5
5025394
6
6
6
1
1
NUT, 3/8-16 HEX NYLOCK FLANGE
5025156
WASHER 3/8” SAE
5025013X8
5400356D
5401074D
BOLT, 3/8-16 X 1” GD5
WELD, BUMPER, SNAPPER Z
WELD, BUMPER, SNAPPER Z
(For Models with Kohler Engines)
(For Models with 20 HP Briggs &
19 HP Kawasaki Engines)
6
7
5023484
6
1
PLUG, PANEL, 1.25 BLACK
5403489D
WELD, BUMPER, SNAPPER Z
(For Models with 24 HP Briggs &
Stratton Engines)
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
37
Decals Group - Brand & Model
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
38
Decals Group - Brand & Model
Item Part No
Qty Description
Note
1
2
3
4
1731955
5100476
5100477
5101328
1
1
1
1
DECAL, SNAPPER, SILVER & BLACK, 8.5"
DECAL, STRIPE, LH, SNAPPER
DECAL, STRIPE, RH, SNAPPER
DECAL, 400Z 24HP
(24 HP Models Only)
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
39
Decals Group - Safety & Common
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
40
Decals Group - Safety & Common
Item Part No
Qty Description
Note
1
2
5100252
5100280
5048970
1725941
5048907
1725072
1725703
--
1
1
1
1
1
1
1
1
1
1
1
1
1
1
DECAL, MAIN
DECAL, THROTTLE CONTROL
DECAL, IGNITION SWITCH
3
4
DECAL, CZT HYDRO RELEASE
DECAL, BELT & BLADE
5
(Located Under Seat)
(Located Under Seat)
6
DECAL-TOUCH UP PAINT
7
DECAL, HEIGHT OF CUT
8
DECAL, US PATENT, ZTR
Not a serviceable part.
Not a serviceable part.
9
--
DECAL, ID PLATE
10
11
12
12
13
5100136
--
DECAL, DANGER, MOWER
DECAL-OPEI CERTIFIED ANSI B71.12003 GOLD
DECAL-44”- SILVER ON BLACK W/STRIPE
DECAL-50”- SILVER ON BLACK W/STRIPE
DECAL, DANGER, MOWER DISCHARGE
Not a serviceable part.
1722789
1722790
5100137
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
41
Export Decals Group - Safety & Common
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
42
Export Decals Group - Safety & Common
Item Part No
Qty Description
Note
1
2
5061108
5100280
5048970
1725941
5048907
1725072
1725703
--
1
1
1
1
1
1
1
1
1
2
1
1
1
2
1
DECAL, MAIN CE
DECAL, THROTTLE CONTROL
DECAL, IGNITION SWITCH
DECAL, CZT HYDRO RELEASE
DECAL, BELT & BLADE
3
4
5
(Located Under Seat)
(Located Under Seat)
6
DECAL-TOUCH UP PAINT
DECAL, HEIGHT OF CUT
DECAL, US PATENT, ZTR
DECAL, ID PLATE
7
8
Not a serviceable part.
Not a serviceable part.
9
--
10
11
12
12
13
14
5061042
1704473
1722789
1722790
1720389
5061217
DECAL, CE DANGER
DECAL, HOT
DECAL-44”- SILVER ON BLACK W/STRIPE
DECAL-50”- SILVER ON BLACK W/STRIPE
DECAL-DANGER ROTATING BLADE SYMBOLS
DECAL, DANGER, CE
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
43
Lift Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
44
Lift Group
Item Part No
Qty Description
PIN, Cotter, 1/8" X 3/4"
Note
1
5025203X6
5100351
1
2
4
2
2
2
2
2
2
2
1
2
20
4
2
4
2
2
6
4
2
4
4
1
1
1
1
1
4
1
2
4
2
1
1
1
1
2
BUSHING, REAR QUICK TACH
SPACER, .53 X 1.00 X 1.44
ADJUSTER, BRAKE LINKAGE
SPACER, .39 X 1.00 X .88
EYE BOLT, 3/8-16 X 6” , 1” EYE
3/32 X 1-5/8 HAIR PIN CLIP N/A
CLEVIS , 1/2-20, STEEL
3
5100144
4
5045947
5
5047125
6
5021812
7
5025210
8
5023174
9
5025328X12
5025096
PIN CLEVIS 1/2” X 1-1/4”
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
NUT, 3/8-16 HEX NYLON LOCK
WASHER, WAVE, M10
5023202
5025018X20
5025394
BOLT, 1/2-20 X 2-1/2” GD5
NUT, 3/8-16 HEX NYLOCK FLANGE
WASHER, .41 X 1.75 X .14
BOLT, 3/8-16 X 1-1/2” GD5
NUT, 1/2-20 HEX NYLON LOCK
BOLT, 3/8-16 X 2” GD5
5025305
5025013X12
5025098
5025013X16
5025128
NUT, 3/8-16 HEX SERRATED FLANGE
WASHER 3/8” SAE
5025156
5025013X8
5100170
BOLT, 3/8-16 X 1” GD5
ROD, DECK LIFT, LINKAGE
WASHER, 5/16” SAE
5025155
5025011X8
5100177
BOLT, 5/16-18 X 1” GD5
SHAFT, HANGER
5100135
SHAFT, HANDLE, DECK SUPPORT
WELD, DECK HANGER, LH
WELD, DECK HANGER, RH
PLATE, DECK HANGER SUPPORT
SPACER, .39 X 1.00 X .25
SAFETY WALK, 4.50 X 3.50
BUSHING, DECK SUPPORT
HAIRPIN
5400391D
5400392D
5400382D
5044960
5044875
5048258
5025210
5021098
BEARING, BRONZE FLANGE 3/4”
WELD, DECK LIFT HANGER REAR
LINK, DECK LIFT SHAFT
WELD, DECK HEIGHT SHAFT
WELD, DECK LOCK
5048711D
5048733D
5400872D
5048884D
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
45
Lift Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
46
Lift Group
Item Part No
Qty Description
SPRING, EXTENSION
Note
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
5020639
5048264
5400370D
5048335
5046092
5100171
5100179
5023198
5400401D
5400839D
5025013X6
5025356
5025011X6
5025013X20
5025392
5021102
5023497
5025089
5100561
1
2
1
1
1
1
1
1
2
2
4
2
2
2
4
4
2
2
2
SPACER, .63 X .39 X 1.50
PLATE, INNER DECK HEIGHT
SPACER, .76 X 1.00 X 1.00
SPACER, .76 X 1.00 X .50
GRIP, BLACK FLEXIBLE
HITCH PIN, 1/2” X 2-1/2”
COVER, VINYL HANDLE
WELD, QUICK RELEASE HANDLE, FRONT
WELD, QUICK RELEASE HANDLE, REAR
BOLT, 3/8-16 X 3/4” GD5
SHOULDER BOLT, 3/8-16 X 1/2 X 3/8
BOLT, 5/16-18 X 3/4” GRD5
BOLT, 3/8-16 X 2-1/2” GD5
NUT, 5/16-18 HEX NYLOCK FLANGE
SPRING, COMPRESSION
EYE BOLT, 3/8-16 X 5", 1" EYE
NUT, 1/2-20 HEX JAM
BEARING, BRONZE FLANGE, 3/4"
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
47
44" & 50" Mower Deck - Belt & Idler Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
48
44" & 50" Mower Deck - Belt & Idler Group
Item Part No
Qty Description
BELT (155" E. L. For 50" Deck)
Note
1
1
5023255
5023256
5044960
5044933
5023157
5025013X22
5025394
5025013X18
5025156
5025013X28
5020095
1676148
5400398D
5047125
5400402
5049003
1674669
1715435
5025392
5048383D
5045023
1
1
1
1
1
1
3
1
2
1
1
2
1
1
1
3
1
1
1
1
1
BELT (151" E. L. For 44" Deck)
SPACER, .39 X 1.00 X .25
SPACER, .39 X .75 X .38
2
3
4
BOLT, 5/16-18 X 1-1/2” FLANGE
BOLT, 3/8-16 X 2-3/4” GD5
NUT, 3/8-16 HEX NYLOCK FLANGE
BOLT, 3/8-16 X 2-1/4” GD5
WASHER 3/8” SAE
5
6
7
8
9
BOLT, 3/8-16 X 3-1/2” GD5
FITTING, Grease
10
11
12
13
14
15
16
17
18
19
20
BUSHING, 5/8 X 3/4 X 13/32, POWDER METAL
ASSM, IDLER ARM 44” SIMPLICITY
SPACER, .39 X 1.00 X .88
WELD, MOUNT, IDLER, TENSION
ASSM, PULLEY IDLER
Spacer
SPRING, EXTEN, 1.0 OD, 6” LG, .118
NUT, 5/16-18 HEX NYLOCK FLANGE
ANCHOR, SPRING
SPACER, .52 X 1.00 X .44
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
49
44" & 50" Mower Deck - Housing, Arbors & Blades Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
50
44" & 50" Mower Deck - Housing, Arbors & Blades Group
Item Part No
Qty Description
NUT, HEX FLANGE, 9/16-18
Note
1
1714419
1713675
1713161
1713613
1655729A
2108202
1715724
1715723
1705897
1707335
1713338
1704314
1664847
5400403D
5022308
1713619
1713609
1713196
1704100A
1708229A
1713089
1656916
2923471
5600107
5600109
1931318
1705115
5401091D
1705449
1960353
1704873
1919326
1723938
1723323
1916964
1916622
5049245A
3
6
3
3
3
3
3
3
3
3
3
3
24
1
2
3
3
3
3
3
3
3
3
1
1
2
1
1
1
2
1
1
1
1
2
2
1
2
WASHER, BELLEVILLE, 9/16
PULLEY
3
4
HUB
5
COVER, ARBOR HOUSING
BEARING, BALL, 3/4 X 1-3/4 X 5/8
SPACER, 21/32 X 3/4 X 5/8
SPACER, 11/16 X 5/32 X 2-11/16
BEARING, BALL, 11/16 X 1-9/16 X 15/32
SEAL, FOAM
6
7
8
9
10
11
12
13
14
15
16
17
18
19
19
20
21
22
23
23
24
25
26
27
28
29
30
31
32
33
34
35
ARBOR HOUSING ASSEMBLY
FITTING, GREASE
(Includes Ref No. 12)
BOLT TAPTITE, 5/16-18 X 3/4
COVER, ARBOR, LH
BODY CLIP, 5/16-18
WASHER, 9/16, BLACK
SHAFT, ARBOR
SHIELD, GRASS, LOWER
BLADE, MOWER, 16-1/8
BLADE, MOWER, 18-1/8
WASHER, HEX, 11/16 X 2
WASHER, SPRING, 15/32, BLACK
BOLT, 7/16-14 X 1-1/4
DECK SHELL W/DECALS, 44” MOWER
DECK SHELL W/DECALS, 50” MOWER
CARRIAGE BOLT, 1/4-20 X 7/8
PLUG, HOLE
(For 44” Deck)
(For 50” Deck)
(includes decals)
(includes decals)
COVER, ARBOR, RH
DEFLECTOR, PLASTIC
WASHER, 1/4, BLACK
CLAMP
WASHER, 5/16, BLACK
SPRING
VINYL CAP
WASHER, LOCK, 1/4
NUT, HEX, 1/4-20
ROD, DEFLECTOR
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
51
44" & 50" Mower Deck - Housing, Arbors & Blades Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
52
44" & 50" Mower Deck - Housing, Arbors & Blades Group
Item Part No
36 5403498D
Qty Description
WELD, MOWER DECK, 50", 400Z MODELS
Note
1
(24 HP MODELS ONLY)
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
53
44" & 50" Mower Deck Roller Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
54
44" & 50" Mower Deck Roller Group
Item Part No
Qty Description
Note
1
2
1714760
4
5
GAUGE WHEEL
5025392
NUT, 5/16-18 HEX NYLOCK FLANGE
CARRIAGE BOLT, 5/16-18 X 3/4
NUT, 3/8-16 HEX NYLOCK FLANGE
CARRIAGE BOLT 5/16-18 X 3/4
SHORT BLOWOUT BAFFLE
3
5025145X6
5025394
3
4
4
5
5025145X8
1724538A
1960027
2
6
1
7
8
WASHER
8
2108765
4
BOLT, REAR WHEEL
9
5049017D
5049018D
5025145X6
5025057
1
BRACKET, GAUGE WHEEL, LH - SNAPPER RED
BRACKET, GAUGE WHEEL, RH - SNAPPER RED
BOLT, 5/16-18 X 3/4", CARRIAGE
NUT, 5/16-18 HEX NYLON LOCK
BAFFLE-BLOWOUT RH 50” MWR - BLACK
BAFFLE-BLOWOUT LH 50” MWR - BLACK
10
11
12
13
14
1
10
10
1
1716869A
1716870A
1
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
55
Control Group Panel
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
56
Control Group Panel
Item Part No
Qty Description
Note
1
2
5022665
5025299X6
5047143
5047629
5049022
5022269
5400717A
1709188
5022222
5022180
5020927
5100978
5025095
5025010X6
5025035
5022789
5022790
5022791
1
1
1
1
1
1
1
1
1
1
1
1
2
2
1
1
1
1
BODY CLIP, 1/4-20 X .500 DEEP
SCREW, ALLEN HEAD, 1/4-20 X 3/4”
CHOKE CABLE
3
4
CABLE THROTTLE, 48”
BRACKET, LOCK
5
6
O-RING, 7/8” ID X 1/16” W
PLATE, CONTROL TANK COVER
HOLE, PLUG DASH
7
8
9
RING, SWITCH RETAINER, PTO
SWITCH, BLADE ENGAGEMENT
SWITCH, IGNITION 6 POST
HOUR METER-DIGITAL
NUT, Hex Nylon Lock, 1/4-20
BOLT, 1/4-20 x 3/4
10
11
12
13
14
15
16
17
18
(Includes Ref. 16 - 18)
NUT, 3/8-24 HEX
KEY, Ignition Molded
(Set of 2)
COVER
PLASTIC NUT
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
57
Electrical Group
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
58
Electrical Group
Item Part No
Qty Description
SWITCH, IGNITION,
Note
1
2
5020927
5022789
5022790
5022791
1725523
5022180
5400371
5048756
5100541
5100540
1960536
5021199
5023222
5048938
5023216
5023217
1724815
5025010X6
5025126
5022182
5021406
5020798
5021542
1722009
5022095
1
1
1
1
1
1
1
1
1
1
2
1
1
1
2
2
1
4
4
2
1
1
1
1
2
(Includes Ref No. 2-4)
KEY, Ignition Molded
3
COVER
4
PLASTIC NUT
5
HOUR METER, DIGITAL
(Includes Retaining Ring)
6
SWITCH, PTO
7
MAIN HARNESS ASSEMBLY
CABLE, #6 X 15” LONG, RING TERMINAL
SWITCH, SEAT, GRAY, NC (Twist in)
SWITCH, SEAT (Screw in)
8
9
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
BOLT, HEX WASHER HEAD PLASTITE, 1/4 X 1/2
CABLE TIE, PUSH MOUNT
CIRCUIT BREAKER, 20A
CRICUIT BREAKER WIRE ASSEMBLY
NUT, HEX JAM, 5/16-24
WASHER, LIGHT LOCK, 5/16
SOLENOID
BOLT, 1/4-20 X 3/4
NUT, HEX SERRATED FLANGE, 1/4-20
SWITCH, PLUNGER, NO/NC, SNAP IN
CABLE, #6 X 22” LONG, RING TERMINAL
BATTERY, 12 VOLT
CABLE, #6 X 30” LONG, RING TERMINAL
STRAP, BATTERY, 14 LONG, RUBBER
SWITCH, PLUNGER, NO/NC
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
59
Wiring Schematic 18hp
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
60
Wiring Schematic 18hp
Item Part No
-- --
Qty Description
Note
1
Wiring Schematic includes harness #5048640
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
61
Wiring Schematic 20hp
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
62
Wiring Schematic 20hp
Item Part No
-- --
Qty Description
Note
1
Wiring Schematic includes harness #5048640
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
63
Wiring Schematic - 24 HP Briggs & Stratton
Manual No.
7006937
HYDRO DRIVE ZTR
SERIES 1
TP 400-5132-F-HZ-N
64
Wiring Schematic - 24 HP Briggs & Stratton
Item Part No
Qty Description
Note
1
2
--
--
1
1
WIRING SCHEMATIC INCLUDES HARNESS # 5402849
WIRING SCHEMATIC INCLUDES HARNESS # 5402479
(CE / EXPORT MODELS ONLY)
Footnotes:
HYDRO DRIVE ZTR
SERIES 1
Manual No.
7006937
TP 400-5132-F-HZ-N
65
Parts Manual for
HYDRO DRIVE ZTR
350Z/400Z
SERIES 1
IT IS THE POLICY OF BRIGGS & STRATTON CORP TO IMPROVE ITS
PRODUCTS WHENEVER IT IS POSSIBLE AND PRACTICAL TO DO SO.
WE RESERVE THE RIGHT TO MAKE CHANGES OR ADD
IMPROVEMENTS AT ANY TIME WITHOUT INCURRING ANY
OBLIGATION TO MAKE SUCH CHANGES ON PRODUCTS
McDonough, GA, 30253 U.S.A.
Briggs & Startton Yard Power Products Group
Copyright © 2007 Briggs & Startton Corporation
Milwaukee, WI USA. All Rights Reserved
Manual No.
7006937
Revision F, 10/15/2007
TP 400-5132-F-HZ-N
|