Parts Manual for
HYDRO DRIVE ELECTRIC CLUTCH
42" & 46" LAWN TRACTOR
LT-125 SERIES
Model No. Description
2690808
2690809
LT23420
LT24460
Briggs & Stratton Yard Power Products Group
535 Macon Road
McDonough, GA, 30253 U.S.A.
800-935-2967
Manual No.
Revision: A
7006275
8/20/2010
Table Of Contents
PAGE GROUP
4
Wheels & Tires Group
6
8
Hood, Grille & Dash Group
Seat Deck & Fuel Tank Group
Steering Group
10
12
16
18
20
22
24
26
28
30
32
34
36
38
40
42
Frame & Front Axle Group
Engine Group - 23HP
Engine Group - 24HP
Controls Group
Transmission Group
Lift Group - Manual
42" Housing, Arbor & Blades Group
42" Mower Deck - Belt, Idler Arm & Hitch Group
42" Mower Deck - Height Adjustment & Roller Bar Group
46" Mower Deck - Housing, Arbor & Blades Group
46" Mower Deck - Clutch Group
Height Adjust Group - Frame Hung Mower
Decals Group - 42" Deck
Decals Group - 46" Deck
Electrical Group
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No. 7006275
TP 400-5424-A-TC-N
3
Wheels & Tires Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
4
Wheels & Tires Group
Item
Part No
Qty Description
17
18
--
7101563
1729708
1742259
2812808
1730181
720258
721318
720010
722598
722620
2
2
4
1
2
2
4
4
6
4
Wheel & Tire, 22 x 10 - 8
WHEEL & TIRE ASSEMBLY, 14.4 X 6
BEARING, Front Wheel, 3/4" ID Hard (Not shown) (Two per wheel)
FITTING, Lube, 1/4 (Not shown)
SPACER, 0.77 ID x 1-1/4 OD x 1.65 LG Powdered Metal Black
KEY, 3/16
--
19
20
21
23
24
26
HUB CAP
RING, "E", .750 D - .050 T
WASHER, .76-1.2 16G FL
WASHER, FLAT
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
5
Hood, Grille & Dash Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
6
Hood, Grille & Dash Group
Item
Part No
Qty Description
1
1728031D
1960295
7102326
1960392
1960518
1728090
1736672
1664847
1919381
1728089
1736671
1732031
1960096
1928707
1732030
1930641
1727295D
1723123
1925003
1933896
1727279A
1728059D
1727294D
7101810
1727296
1727280A
1
HOOD, with Louver, (Red)
2
12 CAPSCREW, Whizlock, 1/4-20 x 5/8
3
1
3
2
1
1
2
2
1
1
1
2
2
1
DUCT, Air Inlet Plastic
SCREW, Pan Head #10-24 x 1/2
NUT, Push Pal
4
5
6
KNOB, Cruise Lock Green Plastic
COVER, Steering Shaft Plastic
CAPSCREW, Hex Head, Taptite, 5/16-18 x 3/4
WASHER, Plain, 5/16
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
KNOB, Brake Lock Plastic
DASHBOARD
GUIDE, Hood RH
WASHER
RIVET, Pop, Stem Black
GUIDE, Hood LH
12 NUT, Hex Flange Whiz, 1/4-20
1
1
1
1
1
1
1
1
1
1
PANEL, Hood LH Side
ROD, Dash Support
SCREW, Self-Tap
NUT, Hex, Nylon, Lock, #10-24
HINGE, Hood LH
GRILLE
PANEL, Hood RH Side
INSERT, Lightbar
HEADLIGHT ASSEMBLY
HINGE, Hood RH
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
7
Seat Deck & Fuel Tank Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
8
Seat Deck & Fuel Tank Group
Item
Part No
Qty Description
SEAT, Hi Back, Steel Pan
1
1736678
1919381
1727268
1960667
1731300
1727265A
1960282
1727266A
1931333
1960686
1729576
1704728
1709256
1704724
1736676
1674231
1654930
1727305
5101651
1736673
1931277
1736674
1727264D
1960536
1930601
1736675
1736679
1731310A
1
4
1
4
4
1
2
1
4
4
2
2
4
2
1
1
1
1
1
1
4
1
1
6
2
1
1
1
2
WASHER, Plain, 5/16
3
LATCH, Seat 20GA E-Coat
CAPSCREW, Hex Head Flange Dog Point, 5/16-18 x 1
SPACER, 0.32 ID x 1-1/2 OD x 3/10 THK Powdered Metal Yellow
SUPPORT, Seat 12GA
4
5
6
7
CARRIAGE BOLT, 5/16-18 x 3/4
PIVOT, Seat 10GA
8
9
BOLT, Carriage, 5/16-18 x 3/4
NUT, Hex Flange, 5/16-18 ESNA
BOLT, Shoulder 5/16-18 G5
SPRING, Compression
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
WASHER, Spring Black
COVER, Spring
POD, LH Cup Holder
ELBOW FITTING
BUSHING
TANK, Fuel
CAP, Gas
PAD, Footrest LH
NUT, Hex, Flange Whizlock, 5/16-18
PAD, Footrest RH
DECK, Seat w/Footrests
SCREW, Hex, Washer Head, Plastite, 1/4-20 x 1/2
SCREW, Taptite, 5/16-18 x 5/8
POD, RH Lift Qua
GRIP, Lift
SUPPORT, Seat
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
9
Steering Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
10
Steering Group
Item
Part No
Qty Description
1
1725024
1960576
1924366
7078088
1611710
1960114
1729665
1727813
1738935A
1930601
1
1
1
1
1
2
2
1
1
4
CAP, Steering Wheel, Plain
2
NUT, Hex Lock, ESNA Light, 5/8-18, Thin
WASHER, 5/8
3
4
STEERING WHEEL, w/Aluminum Insert
RING, Klipring Extension
5
6
WASHER
7
BUSHING, Steering
15
16
17
SHAFT, Steering Gear & Spline Yellow
TOWER
CAPSCREW, Hex Washer Head, Taptite, 5/16-18 x 5/8
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
11
Frame & Front Axle Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
12
Frame & Front Axle Group
Item
Part No
Qty Description
0010
0020
0030
0040
1726504
1611710
2860183
1728018
2
2
4
1
3
2
1
2
1
1
CAP, Hub
RING, Klipring Extension
WASHER, 3/4
AXLE, Front Iron Casting Machined
FITTING, Zerk
0040-10 1704314
0050
0060
0070
0080
0090
0100
0120
0130
0140
0150
0160
0180
0190
0210
0220
0230
0240
0280
0290
0300
0310
0320
0110
0330
0340
0350
0360
0370
0380
0390
0400
0410
0420
0430
0470
0490
0500
0510
0520
1730186
1721918A
1960652
1727902A
2860646
1931277
1731912
1728080A
1727872A
1930645
1727873A
1738937
1727904A
17368760
1930601
1930591
1727905A
1960035
2860744
1727868
1960747
1727252A
1960032
1727269A
1729576
1727935
1727250A
1727246A
1960223
1728024
1728025
1727909A
1727911A
1727282A
1737957
1727940A
1728027
1728122
1934654
BUSHING, Axle Pivot Powdered Metal
HOOK, "J"
CAPSCREW, 7/16-14 x 1.5
PLATE, Axle Support
NUT, Hex Flange Two-Way Lock, 5/8-11
16 NUT, Hex, Flange Whizlock, 5/16-18
2
1
1
2
1
1
1
1
BUSHING, Powdered Metal
ROD, Tie
SPINDLE & CUP ASSEMBLY, RH
NUT, Hex, Flange, Locking, 3/8-16
SPINDLE & ARM ASSEMBLY, LH
FRAME, 12 GA
SUPPORT, Front Footrest RH
SUPPORT, Rear Frame
14 SCREW, Taptite, 5/16-18 x 5/8
14 CAPSCREW, Hex Head, Flange Whiz Lock, 5/16-18 x
1
1
1
1
2
1
2
1
1
1
1
1
2
1
1
1
2
1
1
1
1
2
2
SUPPORT, Front Footrest LH
WASHER, Flat, 5/8
CAPSCREW, Hex Head, 5/8-11 x 3-1/4 G5
LINK, Drag
NUT, Hex Nylock 4
PEDAL ASSEMBLYBrake
CAPSCREW, HeHead, 3/8-16 x , .141 Thread G5
LATCH, Brake Lock
BOLT, Shoulder, 5/16-18 x 1
SPACER, Pivot
PEDAL ASSEMBLY, ward
PEDAL, Reverse
BOLT, Carriage16-18 x 1-1/4
SPACEot Pedal
ACTUR, RMO Switch
BRACKET, Pedal Pivot
PLATE, Bearing
SUPPORT, Battery
LIFT SHAFT ASSEMBLY
BRACKET, Sector Support
GEAR, Steering
SPACER, Sector Gear
CAPSCREW, Hex Flange Whiz Lock, 3/8-16 x 1
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
13
Frame & Front Axle Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
14
Frame & Front Axle Group
Item
Part No
Qty Description
0530
0540
1931211
1727903
2
2
NUT, Hex Flange, 3/8-16
SUPPORT, Transmission
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
15
Engine Group - 23HP
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
16
Engine Group - 23HP
Item
Part No
Qty Description
* ENGINE, 23HP B&S Twin, Mod. 44L777-0128-B1
1
--
1
1
1
4
1
1
1
1
1
4
1
1
2
1
2
2
1
1
1
2
1
1
1
1
1
1
1
2
2
1
2
2
2
2
1717473
1728058A
1930601
1727997A
1727994
1727976A
1727979
1727980
1925003
2834683
1734505
93053
VALVE, Shut Off Oil Drain
SHIELD, Heat
4
5
SCREW, Hex Washer Head Taptite 5/16-18 x 5/8
SHIELD, Heat
6
7
MUFFLER
8
BRACKET, Muffler Mount
PIPE, Exhaust R.H.
9
10
14
15
16
17
18
19
20
21
22
24
25
26
28
29
30
31
32
33
34
35
36
37
38
39
PIPE, Exhaust L.H.
SCREW, Hex Washer Head Taptite 1/4-20 x 1/2
CLIP, Speed Wire
CONTROL, Throttle (Choke a Matic)
CLAMP, Hose
1734993
1730268
2827187
2820427
1924940
1732576
1701011
1732875
1736105
1708264
1918199
1960649
1731214
2828635
94480
HOSE, Fuel
CLIP, Hose
SCREW, Hex Washer Head Taptite 3/8-16 x 1
LOCKWASHER, External Tooth 3/8
WASHER, 3/8
PULLEY & HUB ASSEMBLY, Engine
TIE, Self Locking
RETAINER, Clutch
CLUTCH, Electric OGURA
WASHER, Hex
LOCKWASHER, Spring
CAPSCREW, Hex Head 7/16-20 x 3-1/2 G5
GASKET, Exhaus
SCREW, Hex WashHead Taptite 3/8-16 x 1-1/4
CAPSCREW, HeSocket Head 5x 3/4 G8
LOCKWASHER, Spring, 5/16
SUPPORT, Muffler
1917356
1727982A
1728086
1931335
1931277
PIVOT, Hood
BOLT, Carriage, 5/16x 1
NUT, Hex Flange, 5/1
Footnotes:
NOTE* Purchase engine parts from engine manufacture dealer.
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
17
Engine Group - 24HP
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
18
Engine Group - 24HP
Item
Part No
Qty Description
* ENGINE, 24HP B&S Twin, Mod. 44M777-0139-B1
1
--
1
1
1
4
1
1
1
1
1
4
1
1
2
1
2
2
1
1
1
2
1
1
1
1
1
1
1
2
2
1717473
1728058A
1930601
1727997A
1727994
1727976A
1727979
1727980
1925003
2834683
1734505
93053
VALVE, Shut Off Oil Drain
SHIELD, Heat
4
5
SCREW, Hex Washer Head Taptite 5/16-18 x 5/8
SHIELD, Heat
6
7
MUFFLER
8
BRACKET, Muffler Mount
PIPE, Exhaust R.H.
9
10
14
15
16
17
18
19
20
21
22
24
25
26
28
29
30
31
32
33
34
PIPE, Exhaust L.H.
SCREW, Hex Washer Head Taptite 1/4-20 x 1/2
CLIP, Speed Wire
CONTROL, Throttle (Choke a Matic)
CLAMP, Hose
1734993
1730268
2827187
2820427
1924940
1732576
1701011
1737421A
1736105
1708264
1918199
1960649
1731214
2828635
94480
HOSE, Fuel
CLIP, Hose
SCREW, Hex Washer Head Taptite 3/8-16 x 1
LOCKWASHER, External Tooth 3/8
WASHER, 3/8
PULLEY & HUB ASSEMBLY, Engine
TIE, Self Locking
GUIDE, Belt, Long
CLUTCH, Electric OGURA
WASHER, Hex
LOCKWASHER, Spring
CAPSCREW, Hex Head 7/16-20 x 3-1/2 G5
GASKET, Exhaus
SCREW, Hex WashHead Taptite 3/8-16 x 1-1/4
CAPSCREW, HeSocket Head 5x 3/4 G8
Footnotes:
NOTE* Purchase engine parts from engine manufacture dealer.
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
19
Controls Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
20
Controls Group
Item
Part No
Qty Description
PAD, Foot Pedal Reverse
1
1727259
1727935
1931277
1727898
1728111
1727267
1960268
1727894A
1729620
1728001
1960687
1931335
1728000
1721995
1918447
1727253
1731262
1727261
1722460
1727254
1727899
2159181
1727897
1728976
1721675
1
2
6
1
2
1
2
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
3
SPACER, Pivot Powdered Metal
NUT, Hex, Flange Whizlock, 5/16-18
ROD, Cruise Latch, 16.97LG
CLIP, Linkage, Black
6
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
26
27
28
29
37
ROD, Parking Brake, 16.38 LG Yellow
BOLT, Carriage, 3/8-16 x 1-1/4
BRACKET, Idler 7GA
SPRING, Extension 07.52 LG Black
PULLEY, 3 OD Plastic
NUT, Hex Flange, 3/8-16 ESNA
BOLT, Carriage, 5/16-18 x 1
PULLEY, Idler
SPRING, Extension
PIN, Cotter 3/32 x 3/4
ROD, Brake, 15.1 LG
SPRING, Extension 05.37 LG Black
PEDAL, Brake Rubber
PIN, Quick
ROD, Brake Return, 12.60 LG
ROD, Cruise Latch, 2.83 LG
SPRING, Tension, Clutch
LATCH, Cruise Powdered Metal
BOLT, Shoulder 5/16-18 G5
PAD, Foot Pedal Forward
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
21
Transmission Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
22
Transmission Group
Item
Part No
Qty Description
1
1664847
1728120
1722460
1960686
1960686
1728008
1727258A
1729576
1728043A
1919381
1922127
1931277
1
1
2
1
1
1
1
1
1
1
1
8
CAPSCREW, Hex Head, Taptite, 5/16-18 x 3/4
3
ROD, Bypass, 11.44 LG Yellow
PIN, Quick
4
5
NUT, Hex Flange, 5/16-18 ESNA
NUT, Hex Flange, 5/16-18 ESNA
V-BELT, Drive Belt, Aramid/Kevlar
ARM, Control 7 GA
10
12
13
15
16
17
18
19
BOLT, Shoulder 5/16-18 G5
STRAP, Torque 7 GA
WASHER, Plain, 5/16
CAPSCREW, Hex Head, 5/16-18 x 1-3/4
NUT, Hex, Flange Whizlock, 5/16-18
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
23
Lift Group - Manual
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
24
Lift Group - Manual
Item
Part No
Qty Description
DECAL, Height Of Cut
1
1730264
1960252
1727985A
1930641
1722302
1728070
1921333
1960044
1729652
1728990A
1727935
1931277
1960074
1960170
721221
1
1
1
1
1
1
1
1
1
1
1
3
4
2
2
2
2
2
2
2
2
2
2
1
1
2
CARRIAGE BOLT, 1/4-20 x 5/8 G5
QUADRANT, Lift Height 12GA
NUT, Hex Flange Whiz, 1/4-20
GRIP
3
4
5
6
ROD, Lift Handle E-Coat, 17.7 LG
CAPSCREW, Hex Head, 5/16-18 x 1
WASHER, Plain, 21/64 x 1-1/4
SPRING, Torsion, 2.12 LG Black
CLEVIS, Lift 7GA
7
8
9
10
11
12
15
16
17
18
19
20
21
22
23
24
25
27
28
SPACER, Pivot 0.330ID 1.76OD .37TH Powdered Metal
NUT, Hex, Flange Whizlock, 5/16-18
CLIP, Spring
WASHER, 1/2
PIN, Threaded Shoulder
1731417A
1928352
1732070
1732426
1960687
1666294
1731894
1727955
1727954
1731939
ARM, Lift Rear 10GA
NUT, Hex, Flange, Whizlock, 5/16-18 x 1/2
DECAL, CAUTION! Pinch Point
BOLT, Shoulder
NUT, Hex Flange, 3/8-16 ESNA
SPACER
TRUNNION, Powdered Mtal
ROD, Lower Life, 10.00 LG
ROD, Lift, 5.43 LG
SPRING, Extension 5.10 LG Black
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
25
42" Housing, Arbor & Blades Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
26
42" Housing, Arbor & Blades Group
Item
Part No
Qty Description
1
1960093
721371
2
1
6
1
1
6
1
2
2
1
2
2
2
2
NUT, Push, 3/8
2
ROD, Deflector
3
1931333
721369A
720154
BOLT, Carriage, 5/16-18 x 3/4
BRACKET, Hinge 9 GA
4
5
SPRING, Torsion
6
1931277
721339
NUT, Hex, Flange Whizlock, 5/16-18
DEFLECTOR & SUPPORT ASSEMBLY, Chute Riveted
PLATE, Rear
7
8
721083A
1732354
1731209A
2108202
1922014
7072440
7012491
1923683
1730100D
1704314
7072537
1731372A
7024467
7091633
1731898A
1731917
9
PULLEY, 5.50, .68" Deep-Groove
UPSTOP, "L" 10GA
10
11
12
13
14
15
17
18
19
20
21
22
23
24
BEARING, Upper
NUT, Hex Lock, ESNA Light, 5/8-18, Thin
SPACER, Pulley, 38" Deck
RETAINING RING, Extension, 1-3/4
10 SCREW, Hex, Washer Head, Taptite, 3/8-16 x 3/4
1
1
1
2
4
2
2
2
HOUSING, 42"
FITTING, Grease
SHAFT, Spindle, 38" Deck
TUBE & PLATE ASSEMBLY, Spindle
WASHER, Belleville
NUT, Hex 9/16-18
BLADE, Mower 42"
WASHER, Spindle Blade Powdered Metal
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
27
42" Mower Deck - Belt, Idler Arm & Hitch Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
28
42" Mower Deck - Belt, Idler Arm & Hitch Group
Item
Part No
Qty Description
1
1732884A
2860361
1924356
1731944A
1729007
1922130
1922755
7018574
1931277
1921971
1731911A
1931211
1731311
1930645
1923325
1732955
1
1
1
1
1
1
4
2
2
1
1
2
1
1
2
1
GUARD, Spring
2
CAPSCREW, Hex Washer Head, Taptite, 3/8-16 x 2
WASHER, Plain, 13/32 x 1-1/2 x 1/8
ARM
3
4
5
SPACER, 0.387 ID x 1-1/2 OD x 1.04 LG Powdered Metal
CAPSCREW, Hex Head, 3/8-16 x 2-1/4
WASHER, 3/8
6
7
8
IDLER, Flat
9
NUT, Hex, Flange Whizlock, 5/16-18
CAPSCREW, Hex Head, 3/8-16 X 1-3/4
SUPPORT, Idler
10
11
12
13
14
15
16
NUT, Whizlock, 3/8-16
SPRING, Extension 07.75 LG Black
NUT, 3/8-16, Hex Flange MAC Locking Large, Black
CAPSCREW, Hex Head, 5/16-18 x .88
V-BELT, 94.45 LG A-Wedge Aramid, .44" Deep-Groove
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
29
42" Mower Deck - Height Adjustment & Roller Bar Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
30
42" Mower Deck - Height Adjustment & Roller Bar Group
Item
Part No
Qty Description
1
2108765
1960170
1714760
1931277
1731402A
1960687
1931333
1730072D
1730071D
1731403A
1731966D
1731414
1679166
1960379
2176012
1730221A
1730097
2
2
2
BOLT, Rear Wheel
2
WASHER, 1/2
3
WHEEL, Gauge
4
11 NUT, Hex, Flange Whizlock, 5/16-18
5
1
2
SUPPORT, Gauge Wheel RH 7 GA
NUT, Hex Flange, 3/8-16 ESNA
6
7
11 BOLT, Carriage, 5/16-18 x 3/4
8
1
1
1
1
1
2
2
1
1
1
SUPPORT, Mower RH
10
11
12
13
14
15
16
17
18
SUPPORT, Mower LH
SUPPORT, Gauge Wheel LH 7 GA
HITCH, Front 42" Mower
PIN, Hitch
SPACER, .532 ID x 3/4 OD x 1-1/4 LG Yellow
NUT, ESNA, Lock, 1/2-13 (Thin)
CLIP, Pin, Safety
HANGER, Front Mower
ROD, Bail Mowers Yellow
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
31
46" Mower Deck - Housing, Arbor & Blades Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
32
46" Mower Deck - Housing, Arbor & Blades Group
Item
Part No
Qty Description
0080
0090
0091
0092
0093
0094
0095
0100
0110
0120
0130
0200
0210
0220
0240
0320
0330
0340
0350
0360
0361
0370
0380
0390
0450
0460
0480
0490
0500
0501
0510
0520
0530
1735734D
1735573
1735399
1735326
1735323
1735328
1960766
1960373
1739889
1656916
1920676
1735686
1735579
1736445
1918199
1735447
1736365A
1931333
1931277
1736364
1737359A
1736366
7012542
1923027
1736518A
1736519A
1735752
1735750
1664847
1737279A
1930600
1736898
1735716
1
3
6
3
6
6
6
HOUSING, 46" MOWER
HOUSING, SPINDLE, CAST ALUM MACH'D W/FTG
BEARING, BALL 20MM 46" MWR
SHAFT, SPINDLE 20MM DIA 134.60MM LG
SHIELD, ARBOR 2.050OD 46" MWR
SPACER, BEARING PWDR MTL 46" MWR
RING, SELF LOCKING 46" MWR
10 CAPSCREW, Hex Washer Head Taptite, 5/16-18X1.0 BLK
3
4
5
3
2
1
2
1
1
2
4
1
1
1
2
1
1
1
1
1
7
1
2
1
1
BLADE, MOWER 16.13" LG 46" MWR
WASHER, SPRING 0.475IDX1.75ODX.156TH BLK
CAPSCREW, HEX HD 7/16-14X1.000 G5 BLK
PULLEY, 4.6 OD 11GA SPLIT 46" MWR
SPACER, LOWER DRIVE 46" MWR
SPACER, PULLEY P'MTL 46" MWR ZTR
LOCKWSHER, SPRING .438 BLK
DEFLECTOR, DISCH PLASTIC 46/52 DECKS
PIVOT, HINGE
BOLT, RD HD SH SQ NK 5/16-18X0.750 G5 BLK
NUT, HEX FLANGE 5/16-18, WHIZ LK SM, BLK
SPRING, TORS DEFLECTOR 2.16G 46" MWR
SHIELD, HINGE
ROD, DEFLECTOR, YELLOW
NUT, PUSH, 5/16 BZ
CAPSCREW, HEX HD 7/16-14X1.750 G5 BLK
BRKT, BELT COVER, FRONT
BRKT, BELT COVREAR
COVER, BELT BLAK POLY RH 46 + 52" MWRS
COVER, BELT LH BLACK PLAST" MOWER
CAPSCREW, Hex Washer Head Tae, 5/16-18X0.750 BLK
BAFFLE, PINCHOFF
CAPSCREW, Hex WasheHead Taptite, 5/16-18X1.500 BLK
WASHOUT PORT-CECTOR 46+52" BLK POLY
ADAPTER, WASHOUORT 46+52" PLASTIC
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
33
46" Mower Deck - Clutch Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
34
46" Mower Deck - Clutch Group
Item
Part No
Qty Description
0010
0020
0030
0040
0050
0060
0070
0080
0090
0100
0110
0120
1732956
1715772
1736540
1933685
1924940
1931211
1960339
1736551A
1729007
1923701
1924356
7091585
1
1
1
1
1
1
1
1
1
1
2
1
V-BELT, HA 118.00 LG A-WEDGE ARAMID
SPRING, EXTN 0.987ODX 05.25 LG .112 WIRE
PULLEY, IDLER 46, 52" MWRS
CAPSCREW, HEX HD 3/8-16X2.500 G5 FT BLK
WASHER, 0.375(0.41IDX0.87ODX.08THK) BLK
NUT, HEX FLANGE 3/8-16 WHIZ LK SMALL BLK
NUT, HEX FLANGE 3/8-16 MAC LK LARGE BLK
ARM, IDLER
SPACER, 0.387IDX1.50 ODX1.04 LG PM YELLOW
CAPSCREW, HEX HD 3/8-16X2.000 G5 BLK
WASHER, 0.375(0.41IDX1.50ODX.12THK) BLK
NUT, Center Lock, 3/8-16 YZ
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
35
Height Adjust Group - Frame Hung Mower
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
36
Height Adjust Group - Frame Hung Mower
Item
Part No
Qty Description
0010
0020
0030
0040
0050
0080
0090
0100
0110
0120
0130
0140
0150
0160
0170
0180
0190
0200
0210
0220
0240
0250
0260
1736070A
1736072A
1736073A
1960373
1736071A
1736081
1737059A
1731414
2176012
1679166
1960379
1736074A
1736075A
1931334
1931277
1736896
1736539
1960170
1960687
1736991A
1913744
1960074
1931333
1
1
1
6
1
2
1
1
1
2
2
2
2
SUPPORT, REAR CROSS
BRKT, REAR MOWER PICKUP, TRACTOR
BRKT, REAR MOWER PICKUP, TRACTOR
CAPSCREW, Hex Washer Head Taptite, 5/16-18X1.00 BLK
HITCH, FRONT, 46 / 52 MOWER
ROD, FRONT BAIL 46,52" MWR
HANGER, FRONT MOWER
ROD, LATCH .500DIA 9" LG 42" BLD REG YEL
RETAINER, PIN SPRING FOR .312/.375PIN BLK
SPACER, 0.520ID 0.88 OD 1.185LG P MTL, YEL
NUT, HEX LOCK ESNA LIGHT 1/2-13 THIN BLK
BRKT, GAUGE WHEEL, RH
BRKT, GAUGE WHEEL, LH
13 BOLT, RD HD SH SQ NK 5/16-18X0.875 G5 BLK
13 NUT, HEX FLANGE 5/16-18, WHIZ LK SM, BLK
4
4
6
4
1
2
2
2
WHEEL, GAUGE BLACK POLY 5" DIA
BOLT, SHLDR 3/8-16X3.41 .750 THRD YELLOW
WASHER, 0.500(0.51IDX1.00ODX.10THK) BLK
NUT, HEX FLANGE 3/8-16 ESNA BLK
UP STOP
NUT, HEX JAM 1/2 JAM 1/2-13 NC-2B BLK
CLIP, HAIR PIN .093DIA SPG 625 LG
BOLT, Carriage 5/16-18X.750 G5 Blk
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
37
Decals Group - 42" Deck
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
38
Decals Group - 42" Deck
Item
Part No
Qty Description
1
1736870
7102192
7102191
7102196
1736872
1734879
1730202
1722806
7102194
1704276
1704277
1730264
2
1
1
1
1
1
1
1
1
2
1
1
DECAL, 23HP Snapper
2
DECAL, Snapper LH Stripe
DECAL, Snapper RH Stripe
DECAL, Snapper Rear
3
4
5
DECAL, Snapper Steering Wheel
DECAL, Tunnel
6
8
DECAL, Trans/Tow Release Lever
DECAL, Ignition Switch White/Blk
DECAL, 42" Deck
9
10
11
12
13
DECAL, Danger Blades
DECAL, Danger, Do No Operate without Deflector
DECAL, Mower Height
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
39
Decals Group - 46" Deck
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
40
Decals Group - 46" Deck
Item
Part No
Qty Description
1
1736871
7102192
7102191
7102196
1736872
1734879
1730202
1722806
1704276
1704277
7102193
2
1
1
1
1
1
1
1
2
1
1
DECAL, 24HP Snapper
2
DECAL, Snapper LH Stripe
3
DECAL, Snapper RH Stripe
4
DECAL, Snapper Rear
5
DECAL, Snapper Steering Wheel
DECAL, Tunnel
6
8
DECAL, Trans/Tow Release Lever
DECAL, Ignition Switch White/Blk
DECAL, Danger Blades
9
11
12
13
DECAL, Danger, Do No Operate without Deflector
DECAL, Decal, 46" Deck (Not Shown)
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
41
Electrical Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
42
Electrical Group
Item
Part No
Qty Description
1
2
3
4
5
6
1686734
2101025
1960547
1717549
1717550
1737836
1
1
1
1
1
1
SWITCH ASSEMBLY, Ignition, 6-Pole (Includes Ref. 2, 3, 4 & 5)
WASHER, 5/8
LOCKWASHER, Internal Tooth, 5/8
NUT, Hex, Flange, 5/8-32
COVER, Ignition
KEYS, Blister Pk (KIDS+MWRS DON'T MIX) (set of two, one coated) (Was 1717163 ignition
key, set of 2)
7
1716951
1722611
1729993
1960353
2860293
1931318
1960518
1730007
1732005
1701011
1732007
1732006
1727282A
1930601
1727296
1723451
1677371
1728973
1728974
2172434
1960294
1728097
1721830
1728963
1925003
2820426
2820263
1716549
1931277
1728026A
1931333
1677296
1685215
1732004
2816622
2816964
2821319
1713163
1
1
1
1
1
1
1
1
1
3
1
1
1
4
1
2
2
1
1
1
1
1
1
1
2
2
2
1
2
1
2
1
1
1
2
2
2
1
SWITCH, Headlights, 2 Terminal
PLUG, Hole, Square
8
9
PLUG, Hour Meter
11
12
13
14
15
16
17
19
20
21
22
23
24
25
26
27
28
29
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
WASHER, Plain, 1/4 (6 Total for Export)
NUT, Wing, 1/4-20
CARRIAGE BOLT, 1/4-20 x 7/8
NUT, Push On
HOLD DOWN, Battery
SWITCH, Push Button (NC)
TIE, Self Locking 7-5/16
PLUG, Hole Models W/O 12V Adapter
SWITCH, Push Button (NO/NC)
SUPPORT, Battery 12 GA
SCREW, Taptite, 5/16-18 x 5/8
HEADLIGHT ASSEMBLY InclRef. 24, 25, 26 &
SOCKET ASSEMBLY
BULB, 1141-12V 21CP
REFLECTOR, Headlight
LENS, Headlight
CLIP, Wire
NUT, HexFlang1/4-20
HARNESS, Wiring
CABLE, Solenoid to Starter
SOLENOID
SCREW, Taptite, 1/4-x 1/2
LOCKWASHER, ExtTooth, 5/16
NUT, Hex, 5/16NF
CABLE, 10 ong, with 2 Ring Terminals, Battery to Solen
NUT, lange Whizlock, 5/16-18
SUPPORT, RMO Switch
CARRIAGE BOLT, 5/16-18 x 3/4
BOOT, Insulator
BATTERY
SWITCH, Push Button (NO), Reverse Pedal
NUT, Hex, Full, 1/4-20
LOCKWASHER, 1/4
WASHER, 1/4 I.D.
CABLE, Battery to Ground
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
43
Electrical Group
Manual No.
7006275
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
44
Electrical Group
Item
Part No
Qty Description
48
49
50
51
52
2823341
1731957
1726556
1726557
1722887
2
1
1
1
1
CAPSCREW, Hex Head, 1/4-20 x 3/4
FUSE, Wiring Harness
SWITCH, RMO Module Only
KEY, RMO Module Plastic
SWITCH, PTO, Push/Pull Symbols
Footnotes:
HYDRO DRIVE ELECTRIC CLUTCH
LT-125 SERIES
Manual No.
7006275
45
Parts Manual for
HYDRO DRIVE ELECTRIC CLUTCH
42" & 46" LAWN TRACTOR
LT-125 SERIES
IT IS THE POLICY OF BRIGGS & STRATTON CORP TO IMPROVE ITS
PRODUCTS WHENEVER IT IS POSSIBLE AND PRACTICAL TO DO SO.
WE RESERVE THE RIGHT TO MAKE CHANGES OR ADD
IMPROVEMENTS AT ANY TIME WITHOUT INCURRING ANY
OBLIGATION TO MAKE SUCH CHANGES ON PRODUCTS
Briggs & Stratton Yard Power Products Group
535 Macon Road
McDonough, GA, 30253 U.S.A.
800-935-2967
Manual No. 7006275
Revision: A 8/20/2010
Copyright © 2010 Briggs & Stratton Corporation
Milwaukee, WI USA. All Rights Reserved
|